10kV绝缘导线技术资料

《10kV绝缘导线技术资料》由会员分享，可在线阅读，更多相关《10kV绝缘导线技术资料（19页珍藏版）》请在装配图网上搜索。

1、10kV 绝缘导线技术资料1、产品主要技术性能说明产品简介本产品适用于额定电压35kV及以下的架空电力线路。架空绝缘电缆 的型号、名称及使用范围见表8-1。电缆的机械性能和电性能符合国 家标准GBI4049额定电压10kV、35kV架空绝缘电缆和GBI2527额定电压 1kV 及以下架空绝缘电缆。其中钢芯铝绞线交联聚乙烯 绝缘架空电缆的缆芯结构参照国标GB / T1179圆线同心绞架空导 线，电缆的电性能和绝缘的机械物理性能符合国标 GBl4049 及GBl2527。架空电缆特性及工艺参数【详细说明】Aerial insulated cables with rated voltage up t

2、o and including 0. 6/1KV产品标准本产品按GB1252790额定电压06/1KV及以下架空绝缘电缆及IEC60502额定电压130KV 挤包绝缘电力电缆及附件等标准制造。The produc t is manufac tured according to the st andards of GB 12527-90Aerial insula ted cables of rated volt ages up to and including 1 KVand IEC60502Extruded solid dielectric power cables for rated vol

3、tages from 1KV to 30 KV。使用特性额定电压Uo/U为06/1KVRated voltage Uo/u:0.6/1KV电缆导体的长期允许工作不超过湿度：聚氯乙烯、聚乙烯绝缘架空电缆：70C；交联聚乙烯绝缘架空电缆：90C。Max. permissible continuous temperature:PVC、PE insulated aerial cables:70CXLPE insulated aerial cables:90C.短路时（最长持续时间不超过5秒）电缆导体的最高温度应不超过：聚氯乙烯绝缘架空电缆：160C;聚乙烯绝缘架空电缆：130C；交联聚乙烯绝缘架空电缆

4、：250C。Max.short-circuit temperature of the conductor shall not execeed:PVC insula ted aerial cabl es: 160C;PE insula ted aerial cables: 130C;XLPE insula ted aerial cables: 250C.电缆敷设时环境温度应不低于-20C。than 6 times the diameter of cables .The ins talla tion ambie nt t empera ture should not below 一 20C。电缆的

5、允许弯曲半径：电缆外径（D）小于25mm时，应不小于电缆外径的4倍；电缆外径（D）等于或大于25mm时，应不小于电缆外径的6倍。The bending radius of cables are recommend as follows:When the diameter of cables less than 25 mm : not less than 4 times the diameter of cables ;When the diameter of cables not less than 25 mm : not less当电缆使用于交流系统时，电缆的额定电压至少应等于该系统的额定电压

6、；当电缆使用地直流系统 时，该系统的额定电压应不大于电缆额定电压的15倍。When the cables use in alternating current system, rated voltage of cables should be at least equal the rated voltage of the system; When the cables use in direct currentsys tem,ra ted voltage should be not greater than 1.5 times of the rated volt age of the cabl

7、es 电缆的型号、名称型号Type名称 Designation主要用途Main usefulnessJKV铜芯聚氯乙烯绝缘架空电缆Copper conductor PVC insulated aerial cables架空固定敷设、引户 线等JKLV铝芯聚氯 乙烯绝缘架空电缆Aluminum conductor PVC insulated aerial cablesJKLHV铝合金芯聚氯 乙烯绝缘架空电缆Aluminum alloy conductor PVC insulated aerial cablesJKY铜芯聚乙烯绝缘架空电缆Copper conductor PE insulated

8、aerial cablesJKLY铝芯聚乙烯绝缘架空电缆Aluminum conductor PE insulated aerial cablesJKLHY铝合金芯聚乙烯绝缘架空电缆Aluminum alloy conductor PE insulated aerial cablesJKYJ铜芯交联聚乙烯绝缘架空电缆Copper conductor XLPE insulated aerial cablesJKLYJ铝芯交联聚乙烯绝缘架空电缆Aluminum conductor XLPE insulated aerial cablesJKLHYJ铝合金芯交联聚乙烯绝缘架空电缆Aluminum a

9、lloy conductor貝二三s-路密予董3一壬 T-i-z .-7.E迂送君蚪z11寸 CQ ao t-H寸03O寸 z ao额定电压 Rated Voltage kvt-HCD6芯数 Cores Numbert-H寸&*ooS1JKV、JKLV、JKLHY、JKY、JKLY、JKLHY、JKYJ、 JKLYJ 、 JKLHYJ 、 JKLGV 、 JKLGY 、 JKLGYJJKLV 、 JKLY 、 JKLYJ钢芯铝绞线芯聚氯乙烯绝缘架空电缆ACSR conductor PVC insulated aerial cables钢芯铝绞线芯聚 乙烯绝缘架空电缆ACSR conductor

10、 PE insulated aerial cables11JKLGYJs*qe。le.l-l.Iae p9+-efns.sHdxI 导体(铜的或粥合金)亍绅圾r : ml ., . Jji S3俱别标志4钢芯命绞线芯屮钢芯5承饑芯6飙带I (.HHidLichir-Irisiilulinn3 IdcnLilirnHicri tnark4 Slcel in ACSR5 The 、咒:i 百hl beunng core6 llril !)ini I hipeJKLHYJ/QJKLY/y JKHIY/Ql別术2制芯廊走:阳狡线芯)3绝探4导休加蔽1 CiJtdu-lor2 Sh id (umc,|k

11、!X；Y/O3 Insuhuion4 Cnnductor sciniidiJKY.I JKLYJJKLHYJ JKYJKI.Y JKLHYJKTRYJ、KTRJKLGYJJ KI GY电缆的结构和技术参数詞芯S铝芯或铝合金芯架空绝緣电缆(二芯)(JKV-, JKY. JKYJ. JKLY. JKLYJ. JKLHV. JKLHY. JKLHYJ)Copper aluitmiuitL and aluininuin kalhy conductor aerial insulated cables (two core)导体标 称截面 Nominal crosss-ec tion of conducto

12、导悻参考 外径Conductoapprox.di ameter绝緣标 称厚度 Insulati on no ininathickne ss电缆 参考 外径 cable appro x.dia meter电缆参考車暈Cable approx.weight计算电缆拉斷力 Cable draggle force at breakJKVJKYJKYJJKLVJKLHVJKLYJKLYJJKJHYJKLHYJ硬詞HaidCupper铝芯 Ahi rriiiL utn铝合 金芯 Alu nun um Alh7Mm-mmmmnmLKg/kmN103.81.011.6228216102896!35164.81

13、.214.4361343153140109750243044256.01.216.S521500217195169375241256357.01.419.6733704302272234610351760508.31.422.2969937387352330014022513709.81.425.21336130513473笛92207035199511.51.629.4188218371566263512745477612012.91.632.22343229S7281579S23467603215014.51.336.229542831098102599014206754118516.02

14、.040.03536345132012311236rn5346930030020.52.450.65891577216820321995768669150822铜芯.铝芯或铝合金芯架空绝鳏电缆(四芯)(JICV-, JK认 JKYJ. JKLY-, JKLHV. JKLHY. JKLHYJ 5Copper aluiriitiuin and almtihiuin alloy conductor aerial insulated cables (four core)导体标 称截面 Nominal导体参考 外径Conducto绝鳏标称 厚度 Cable电缆参考重量Cable approx.wieig

15、ht计算电缆拉斷力 Cable draggle force at breakcross-sec tion of conductoapprox.di ameterappnox.di aineterJKVJKYJKYJJKLVJKLHJKLYJKLYJJKJHYJKLHYJ硬铜Haidcopper铝芯AlutriitLurn千口 口圭芯AlutriiiLHtCLAlloyMm2nunimnKg/kmN103.81.045643420417913884660010056164.81.2721687316280219441004316088256.01.210401001433390338601504

16、325136357.01.41464141060454646924207083520050g.31.419361876773706660082804450276709.81.42669260110259489384441416703849511.51.63761367214291327127036549089552012012.91.646924597174416321596446935612065615014.51.859035782219720541980208413215082418516.02.0706569162641246624768410692818601224018.32.29

17、210902634183199319292138716241316钢芯铝餃线芯架空绝緣电缆(单芯)Copper aluinirLUin and aluiriinuin alloy aerial insulated cables (single)导悻标称截 面 Noininal cross-section f conductor导体外径 Conductor approx.diam eter绝緣标称 厚度IrisulatiDn no initial thickness电缆参考外 径Single cable approx.diainje ter电缆参考重量 Single cable approx.w

18、eight电缆拉斷力Single cable draggle force at breakJKLjGVJKLGYJJKLjGYMm2minICLtrLICLtrLKg/kmN25/46.61.29143131929035/67.81.410.61991831263050/S9.11.411.92622431687050/3011.11.413.94474244262070/1010.91.413.735533423390TDMO13.11.415.96035785830095/1512.91.616.14864573500095/2013.11.616.35144S43720095/5515.

19、31.61S.58277937S110120/713.61.616.843645527570120/2014.41.617.658955741000120/2514.71.617.9634602478801207017.21.620.4102598798370150/S15.11.81S.761057232860150/2015.81.819.4702663恥曲Ci150/2516.11.819.774870854110150G516.61.820.283279165020185/1016.72.020.775170410880185/2517.62.021.687282359420185G0

20、17.82.021.891686764320185/451S.42.022.4102997880190210/1017.92.021.984779845140210/2518.82.022.898193065990210G519.12.023.1104298974250210/5019.72.023.7116211089083024JG020.02.224.411221061756202娥4020.32.224.7118211208337024J/5521.02.225.4713271263102100300/1521.42.426.21196112568060300/2021.62.426.

21、412421171756S0300/2521.92.426.71294122283410300/4022.32.427.11392131992220300/5022.72.427.514761103400厂i 门 ifc_?ri- j!1 ffLl1兀匚兀1nQnnn电气性能 Electiical properties导体标称截NominalCross-sectionOf conductor时导体直疣电阻d. c. r e e i e tzncE uf c cm due tor at 2LIC工作温度时摄 小绝緣电阻Min.insulation nesistaiuce of works tem

22、perature詞 Copper铝gm瓠钢芯铝绞701C硬Haid软FlexibleAluinitiumAluinitium alloy线ACSRnnn20/kmMO .km101.9061.833.083.5743.080.0060.67161.1981.151.912.2171.190.0060.65250.7490.7271.201.3031.200.0050.54350.5400.5240.8681.0070.8680.0050.54500.3990.3870.6410.7440.6410.0040.46700.2760.2680.4430.5140.4430.0040.40950.1

23、990.1930.3200.3710.3200.0030.391200.1580.1530.2530.29640.2530.0030.351500.1280.1240.2060.2390.2060.0030.351850.10210.09910.1640.1900.1640.0030.35240.07770.07540.1250.1450.1250.0030.343000.06190.06010.1000.1100.1000.0030.33交流电压试验：3KV,lmm不击穿口Alternate voltage test:3Kl min non -breakdowrin绝緣材料的机械物理性能要求

24、（老化前和老化后）Requirements for mechanical characteristies of insulated materials （before and afier a举 in或序号NO性能Property单位Unit技术指标Technical index材料名称 Maieerial djesignation聚氯乙烯PVC聚乙烯PE交联聚乙 烯 XLPE1未老化前 Without ageing1.1抗张强度 摄小 tensile strengthN/inin212.5101.2斷裂忡长率 摄小 Ehngation-at-br eak%1503002空气箱老化后 性能Aft

25、er ageing iii：iif ovefL2.1抗张强度Tensile streruth ttiitL.N/mm-12.52.2抗张强度变化 率杲犬tensile strength variation max%202.3斷裂忡长率Ehngation-at - breakmin%1503002.4斷裂伸长变化 率摄大Ehngation -at -break vanatioii max%253人工气候老化 后性能After ageing of manual climate3.10100S小时0-1008 hour3.1.1抗张强度娈化 率摄丈Tensile strengthvariation

26、max%3030303.1.2断裂伸底变化 率Ehngation -at-break vaiiatiDn%3030303.25041008 小时504-100S hour3.2.1抗张强度娈化 率%303030注明:关于电缆的其他技术参数详见所提供的产品样本4、产品工艺流程图单芯电缆非交联型 非铠装型3、主要原材料供应厂家一览表原材料名称生产厂家名称和地址无氧铜杆1.湖北黄石鑫鹏铜业有限公司铝杆1.郑州万达电缆厂内外屏蔽材料1.上海万益/上海古浪路1340号2苏州市双虎高能材料公司/苏州市横塘镇交联聚乙烯XLPE绝缘材料1. 上海新上化/上海杨树浦路1578号2. 浙江万马高分子材料公司/杭州

27、市临安锦城兰巾工业区3. 上海化工厂/上海市普陀区中山北路2918号PVC绝缘及护套材料1. 纽表特科强电缆材料有限公司/芙湖市褐山路115号2. XXXXXXXXX镀锌钢带1. 绍兴申越电缆带钢有限公司/绍兴市孙端镇三条娄村2. 上海三泠钢带厂/上海宝山区南陈路281号无纺布、矿物阻燃填充料1. 江阴无纺布包装材料有限公司/江阴市璜塘镇环东路2. 江阴长泾电缆附件厂/江阴市长泾镇人民路243号阻燃玻纤带1. 绍兴马山玻纤厂/绍兴市乐山镇北路2. 上虞市新科复合材料厂/上虞市道墟镇方桥工业区耐火云母带1. 广州盈科新材料制品有限公司/广州天河区塑金胡工业 区2. 深圳胜比达电工材料有限公司/罗

28、湖区翠竹路佳北商业 大楼2）主要生产设备名称规格型号数量用途拉丝机大拉1铜杆连拉丝带退火拉丝机中拉2铜杆连拉丝带退火铝大拉机组LFD-450/106铝杆拉丝对绞机MF473绝缘线芯绞对管式绞线机组1+6/4001绞制10-50mm2导体54B框绞机JLK-12+18+24/4002绞制50-800mm2导体30B笼绞机12+18/4002控制电缆成缆、电力电缆导体绞制大3B成缆装铠机JC-1800/3+212-5芯成缆、钢带铠装，最大可生产400mm大3B成缆装铠机JC-1600/3+222-5芯成缆、钢带铠装，最大可生产400mm大6B成缆装铠机1+6/12501钢带铠装外径100mm、2-

29、7芯成缆6B成缆机1+6/4001小规格电力电缆、控制电缆的成缆、 铠装成缆机（通信电 缆）CPL502绞对线芯成缆挤塑机SJ120252护套生产挤塑机SJ90253绝缘、护套生产挤塑机SJN-651绝缘线芯挤出挤塑机SJ45253绝缘线芯挤出高速编织机GSB-16 锭2屏蔽编织高速编织机GSB-24 锭1屏蔽编织多米诺喷码机A2006电脑智能喷码束丝机JS-2/4002节距6.60-120mm束绞铜导线3）检测设备名称规格型号数量主要检验项目（用途）拉力试验机LJ5001拉力试验自然通风老化烘 箱XG2001绝缘护套老化试验直流双臂电桥QJ441上海正阳仪表厂（导体电阻）直流双臂电桥QJ57

30、1上海正阳仪表厂（导体电阻）分析天平TGA832A1线路故障测试仪QJ451线路故障测试投影仪LY1FA1绝缘护套厚度测试高阻计2C901绝缘电阻测试数字绝缘电阻测 试仪PC272H1绝缘电阻测试电容测试仪FUEE1电容测试交流耐压试验台AHD225/501高压测试热延伸试验装置自制1父联电缆热延伸试验切片机自制1绝缘护套试样制备冲片机自制1绝缘护套试样制备火花机GP20 40023绝缘在线检测使用条件表 3-1 使 用 条 件序号名称单位项目单位要 求值投标人保 证值1周围空气温度最高气温C+ 40+ 40最低气温2020最大日温差K25252海拔m3太阳辐射强度W/cm20.10.14覆冰

31、厚度mm6最大风速m /s7湿度日相对湿度平均 值%W95W95月相对湿度平均 值W90W908耐受地震能力水平加速度m/s20.2g0.2g地面垂直加速度0.125g0.125g安全系数/1.671.67表 4-1 绝缘线技术参数响应表项目单位招标人要求 值投标人保证 值结 构绝缘 线单 线股数/直径根/mm国标国标计算截面 积合计mm2国标国标铝合金mm2国标国标钢mm2国标国标外径mm国标国标单位长度质量kg/km国标国标20 C时直流电阻Q/km国标国标额定抗拉力kN国标国标弹性模量GPa国标国标线膨胀系数1/C国标国标绝缘老化前抗张强度不小于MPa12.512.5老化前断裂伸长率不小

32、于%200200老化后抗张强度变化率不超 过%2525老化后断裂伸长率变化率不 超过%2525电缆段老化后抗张强度变化 率不超过%2525电缆段老化后断裂伸长率变 化率不超过%2525绝缘收缩试验不大于%44热延 伸性负荷下伸长率不大于%175175冷却后永久伸长率不 大于%1515每盘线长m国标国标线长偏差正%国标国标负%国标国标项目单位招标人要求 值投标人保证 值每盘绞线净重kg/每盘绞线毛重kg/老化特性21d蠕变量%42d蠕变量%备注：4.2 技术差异表投标人提供的产品技术规范应与技术规范书中规定的要求一致。 如有差异投标人应如实、认真地填写差异值；若无技术差异则视为满 足本技术规范的要求，且在技术差异表中填写“无异差”。表 4-2 技术差异表附录 B 技术参数通用部分条款变更表序号变更条款页码、款号变更内容原表述变更后表述1234无变更内容注 本表是对技术规范“通用部分”的补充和修改，如有冲突，应 以本表为准。