某公司200L纯水系统方案

《某公司200L纯水系统方案》由会员分享，可在线阅读，更多相关《某公司200L纯水系统方案（13页珍藏版）》请在装配图网上搜索。

1、 Xxxx公司200L/h工业纯水系统方案及报价公司简介1工艺方案及说明2系统报价3技术指标及服务保证4 施工单位：xxxx公司日 期：2011年5月公司简介Xxxxxxxx公司,专业从事清洗、水处理技术的科研及服务。公司在清洗、原水处理、循环水处理、废水处理等领域为客户提供优质的产品及服务；公司专业生产各类型纯水设备，节能装置及污水回用设备等。公司拥有国家工业水处理工程技术研究中心雄厚的技术后盾，积累了丰富的现场服务经验，多年来为冶金电力，化肥，化工，食品，纺织，造纸、电子、医药、生产制造等行业提供各类水处理药剂、专用化学品及清洗、设备安装工程服务。可根据不同水质，生产工艺等工况条件，提供相

2、关服务等。公司主要优势技术先进拥有多种独特配方和先进技术，在水处理药剂、水处理设备等领域是始终占有领先地位。技术成熟多年来在服务中积累了丰富的经验，为雀巢食品、百事可乐、可口可乐、波海航空、三星通讯、三星视界、卡博特化工、平和汽车部件、一汽丰田、赫比电子、松下电子部品等企业长期提供服务。技术服务公司有一批高素质的现场服务技术工程师，建立完善的用户服务档案，能为客户提供全过程的技术服务，随时解决现场问题。一、设计方案及说明：（一）、设计条件1、 原水为天津市政自来水,水质符合国家（生活饮用水卫生标准）2、 原水压力0.3Mpa （如无法保证，需设辅助加压泵）3、 纯水水量：200L/h4、 设备

3、配置数量：200L/h（二）、设计方案及说明：1、工艺流程图电导检测产品水箱市政供水活性碳过滤器软水器5m过滤器高压泵用水点紫外线消毒设备RO系统精砂过滤器辅助清洗设备2、系统简述本系统是取自市政自来水，经砂滤、碳滤、软化、活性炭滤芯、5m过滤器、RO系统、紫外线消毒、纯水箱等制水工艺流程。设备产水量为200L/h，以满足生产车间工作人员饮用水需要。（1）、预处理 ：过滤、软化（2）、反渗透脱盐 ：RO系统（3）、产品水储存输送：消毒、管网、液位（4）、电空系统：自动/手动原水，含悬浮物及少量有机物、微生物等杂质，通过精砂过滤器或滤芯过滤器可去除大量悬浮物及部分有机物、微生物，保证过滤效果。过

4、滤后出水进入全自动软水器，除去水中的硬度，尤其是Ca2+、Mg2+硬度。防止反渗透膜形成结垢性堵塞。软化水进入活性炭滤芯过滤器，去除有机物和余氯，防止RO膜被氧化或遭受微生物污染，即达到水质预处理目的。预处理出水再经过5m过滤器后，进入反渗透系统。反渗透系统设计采用世界上高脱盐率的反渗透膜（膜脱盐率99），RO系统不仅可去除水中溶解的无机盐，更为重要的是几乎全部去除水中的胶体、有机物、微生物等杂质。RO系统为全自动运行（配备手动操作的功能），由控制系统给出报警指示，在允许的时间内如果故障未能清除，系统自动停机，以免出现不可恢复的损坏或影响后续设备运行及使用。二、配置详细说明：1、原水箱作用：克

5、服供水的不稳定性，保证整个系统的供水稳定连续；同时也给各设备长期性能可靠提供了保障。选型：PE材质水箱。控制：水箱配置高水位浮球阀和低水位液位开关。其具备了可靠性高,价格低廉,结构简单,安装方便等优点。当水位处于高位时，浮球阀关闭，停止进水。水位处于低水位时，高水位浮球阀打开，开始向水箱注水。同时，低水位液位开关断开，增压泵停止工作。2、增压泵作用：给预处理各设备提供必需的工作压力。选型：根据预处理各设备设计压力降（每台过滤设备最大压降0.05Mpa），以及高压泵前压力不能小于0.5Kg/cm2，确定增压泵的工作压力。3、机械过滤器作用：原水首先经过机械过滤器，在过滤器中放置精致石英砂，使原水

6、中的絮凝体、铁锈等悬浮杂质在此过程中被截留。由于机械过滤器在工作中截留了大量的悬浮杂质，为保证过滤器的正常工作，必须对过滤器定期进行冲洗、反冲洗。选型：选用玻璃钢材质容器.控制：机械过滤器的反洗操作采用手工或自动控制器，过滤器应每天进行一次清洗，清洗时间为10-20分钟。4、活性碳过滤器作用：本工艺采用活性碳过滤器，作为反渗透装置的予处理，是非常重要的。反渗透系统要求进水指标SDI5，余氯0.1mg/L。为满足其进水要求，需进一步纯化原水，使之达到反渗透的进水指标。在反渗透装置前设置碳滤器，主要有两个功能：1、吸附水中部分有机物，吸附率为60%左右；2、吸附水中余氯。吸附粒度在10-20埃左右

7、的无机胶体、有机胶体和溶解性有机高分子杂质以及在砂滤器中是难以去除的余氯。活性碳之所以能用来吸附粒度在几十埃左右的活性物，是由于其结构存在大量平均孔径在20-50埃的微孔和粒缝隙，活性碳的这个结构特点，使它的表面吸附面积能够达到500-2000m2/g，由于一般有机物的分子直径略小于20-50埃，因此活性碳对有机物具有很强的吸附作用。此外活性碳具有很强的脱氯能力，由于余氯具有很强的氧化性，余氯和碳起反应，生成二氧化碳和-1价氯离子，因此只是损失了少量的碳，所以活性碳脱氯可以使用相当长的时间。活性碳不仅仅具有以上功能，还能够去除水中的异味、色素，提高水的澄明度，活性碳使用一段时间后，其吸附能力下

8、降，需要进行再生或更换。所以，原水通过碳滤器后，能大大提高水质，减少对反渗透膜的污染，经过处理后的水质都能达到反渗透装置进水水质要求（余氯0.1mg/L）。选型： 选用玻璃钢材质容器，膨胀率40%。控制：活性碳过滤器的控制采用自动控制器，由于活性碳过滤器在工作中吸附了大量的悬浮杂质，为保证系统正常工作，每天必须进行冲洗、反冲洗，冲洗过程由清洗时间为15-30分钟。5、全自动软化水器作用：除去水中硬度（Ca2+ 、Mg2+）的过程称为软化。本设备装填0017强酸型Na离子交换树脂，（如为食品，制药企业建议采用食品级树脂）用钠离子置换原水中的钙、镁离子，使原水中的残余硬度低于0.03mmol/L。

9、软化的目的是防止反渗透膜表面结垢，以延长反渗透膜的使用寿命和处理效率。选型：软水器为玻璃钢材质容器，控制：控制系统采用美国自动控制阀型。按已设定的时间/流量，控制阀头可自动再生树脂，完成吸盐反洗，正冲注水过程。软水器配备一个再生箱，应每日检查盐箱的盐量及水量，并及时补充盐（禁止使用加碘盐及其他有添加物的盐）。6、精密过滤器作用：精密过滤又称为保安过滤器。它是原水进入反渗透膜装置前的一道处理工艺。PP过滤芯具有过滤流量大，纳污量大，压力损耗小的特点，可阻截不同粒径的杂质颗粒，集表面过滤与深层过滤于一体。精密过滤器使用一定时期后也有堵塞现象，因此，一定时期后PP熔喷滤芯必须更换，更换依据：精密过滤

10、前后的压力差在0.05-0.1Mpa时更换。选型：选用不锈钢材质容器.7、高压泵作用：高压泵是提供给反渗透系统所需产水流量及水质的工作压力。使过滤水经过泵体后满足膜体的进水压力，保证纯水的出水量。选型：根据反渗透膜所需的工作压力，采用南方特种泵业出产的高压泵.控制：当原水压力表指针达到2KG时，按下产水开关，高压泵启动，开始产水。高压泵前设有压力保护开关，当进水压力低于1KG时，压力保护开关关闭，高压泵停止工作。8、反渗透装置作用：反渗透装置是纯化水生产线的主要部分。采用美国海德能的反渗透膜元件。ESPA系列为高脱盐率苦咸水淡化膜。可在较低操作压力下，获取高水通量，其平均脱盐率99.5%。 由

11、于ESPA膜具有上述的优点，从而为水泵、压力容器、管道、阀门等配套设备的选择提供了更为广泛的空间。而且使用功率更小的电机即可满足工作的需要。同时，ESPA膜的高水通量、高脱盐率的特性，这些都使设备制造成本和系统设备投资费用大为降低，并且可大量的节省能源，降低了系统的运行费用，提高水质。选型：美国海德能ESPAI-4040。反渗透装置所设计的产水温度25，水的利用率为75%。9、产品水箱（成品水箱）作用：反渗透装置出水，进入纯化水箱，再通过纯化水箱送至各用水点。 控制：纯化水箱内设有高，低液位开关，控制反渗透装置的给水泵。当纯化水箱处于低水位时，反渗透装置给水泵开始工作，向纯化水箱注水；高水位时

12、，反渗透装置给水泵停止工作。10、检测仪器仪表1）、反渗透主机设有膜前压力表和膜后压力表，对膜的工作压力进行检测，并设有系统路径运行显示，淡水流量计和浓水流量计检测浓、淡水流量。2）、反渗透主机还设有电导率仪，在线检测淡水水质，既直观又方便三、系统报价200L纯 水 配 置 报 价序号设 备 名 称型 号 规 格设备用量产 品 产 地材质价格1原水箱0.5TPE8002原水泵CHL2-30南方泵业9503自动精砂过滤器WZF2501套天津1500 罐体25015001只鑫磊玻璃钢 控制系统255440美国Autotrol 精制石英砂60L中国 管路仪表1套4全自动软水器GWT1A Q300L/

13、h 罐体25015001只天津玻璃钢1950 盐箱4008001个天津L玻璃钢 控制系统255440 树脂60L英国漂涞特 管路仪表1套5活性碳滤芯过滤器1套美国1800 滤壳、滤芯2010m1套 压力表2块 取样阀2个 管路、阀门1个65m过滤器1套650 滤壳、滤芯205m1套 压力表2块 取样阀1个 管路、阀门1套7反渗透装置1套 高压泵21301台南方1980 膜ESPA40401只美国 HYDRANAUTICS1750 压力外壳1只SS304420 流量计2块进口400压力表2块进口160 电导仪CM230型2块进口760 电控系统进口元器件1套2550 柜式支架1套不锈钢10008

14、纯化水贮罐1.0m31台不锈钢SS3041500 液位控制1套9紫外线消毒器1台国产SS30478010阀门、管件1批280011变频输出泵1台175012安装调试及运费4500系统设备总计 28000元（贰万捌仟元整）备注： 1、以上报价含税17%。 2、以上报价整套设备一年内免费维护。3、以上报价RO膜三年以内出现膜本身质量问题，我公司免费维护。其详细说明见海德能公司膜使用手册4、我公司提供设备详细说明及运行维护操作说明。四、技术指标及服务保证（一）、技术指标1、反渗透RO系统水利用率752、产品水电导率20cm/S（市政自来水）3、供水能力200L/h（产品水）4、RO膜使用寿命不低于3

15、年（我公司包括海德能厂家承诺除不可抗拒及误操作、人为损坏等外在原因）并建议RO膜每年做一次清洗。（二）、质量服务保证。1、提供甲方一年免费维护。2、严格认真培训操作管理人员，提供详细培训管理资料。系统运行3个月内，接到客户通知，相关人员24小时内到达现场，解决问题。3、定期回访用户，确保设备正常运转。验收后一年内每三个月检查运行情况一次。验收后一年内指导系统化学清洗一次。4、长期提供工程相关设备、材料备品备件、技术咨询及技术服务。g an employment tribunal claimEmployment tribunals sort out disagreements between e

16、mployers and employees.You may need to make a claim to an employment tribunal if: you dont agree with the disciplinary action your employer has taken against you your employer dismisses you and you think that you have been dismissed unfairly.For more information about dismissal and unfair dismissal,

17、 seeDismissal.You can make a claim to an employment tribunal, even if you haventappealedagainst the disciplinary action your employer has taken against you. However, if you win your case, the tribunal may reduce any compensation awarded to you as a result of your failure to appeal.Remember that in m

18、ost cases you must make an application to an employment tribunal within three months of the date when the event you are complaining about happened. If your application is received after this time limit, the tribunal will not usually accept it.If you are worried about how the time limits apply to you

19、, take advice from one of the organisations listed underFurther help.Employment tribunals are less formal than some other courts, but it is still a legal process and you will need to give evidence under an oath or affirmation.Most people find making a claim to an employment tribunal challenging. If

20、you are thinking about making a claim to an employment tribunal, you should get help straight away from one of the organisations listed underFurther help.If you are being represented by a solicitor at the tribunal, they may ask you to sign an agreement where you pay their fee out of your compensatio

21、n if you win the case. This is known as adamages-based agreement. In England and Wales, your solicitor cant charge you more than 35% of your compensation if you win the case.If you are thinking about signing up for a damages-based agreement, you should make sure youre clear about the terms of the ag

22、reement. It might be best to get advice from an experienced adviser, for example, at a Citizens Advice Bureau. To find your nearest CAB, including those that give advice by e-mail, click onnearest CAB.For more information about making a claim to an employment tribunal, seeEmployment tribunals.The (l

23、ack of) air up there Watch mCayman Islands-based Webb, the head of Fifas anti-racism taskforce, is in London for the Football Associations 150th anniversary celebrations and will attend Citys Premier League match at Chelsea on Sunday.I am going to be at the match tomorrow and I have asked to meet Ya

24、ya Toure, he told BBC Sport.For me its about how he felt and I would like to speak to him first to find out what his experience was.Uefa hasopened disciplinary proceedings against CSKAfor the racist behaviour of their fans duringCitys 2-1 win.Michel Platini, president of European footballs governing

25、 body, has also ordered an immediate investigation into the referees actions.CSKA said they were surprised and disappointed by Toures complaint. In a statement the Russian side added: We found no racist insults from fans of CSKA.Age has reached the end of the beginning of a word. May be guilty in hi

26、s seems to passing a lot of different life became the appearance of the same day; May be back in the past, to oneself the paranoid weird belief disillusionment, these days, my mind has been very messy, in my mind constantly. Always feel oneself should go to do something, or write something. Twenty y

27、ears of life trajectory deeply shallow, suddenly feel something, do it.一字开头的年龄已经到了尾声。或许是愧疚于自己似乎把转瞬即逝的很多个不同的日子过成了同一天的样子；或许是追溯过去，对自己那些近乎偏执的怪异信念的醒悟，这些天以来，思绪一直很凌乱，在脑海中不断纠缠。总觉得自己自己似乎应该去做点什么，或者写点什么。二十年的人生轨迹深深浅浅，突然就感觉到有些事情，非做不可了。The end of our life, and can meet many things really do?而穷尽我们的一生，又能遇到多少事情是真正地非

28、做不可？During my childhood, think lucky money and new clothes are necessary for New Year, but as the advance of the age, will be more and more found that those things are optional; Junior high school, thought to have a crush on just means that the real growth, but over the past three years later, his w

29、riting of alumni in peace, suddenly found that isnt really grow up, it seems is not so important; Then in high school, think dont want to give vent to out your inner voice can be in the high school children of the feelings in a period, but was eventually infarction when graduation party in the throa

30、t, later again stood on the pitch he has sweat profusely, looked at his thrown a basketball hoops, suddenly found himself has already cant remember his appearance.童年时，觉得压岁钱和新衣服是过年必备，但是随着年龄的推进，会越来越发现，那些东西根本就可有可无；初中时，以为要有一场暗恋才意味着真正的成长，但三年过去后，自己心平气和的写同学录的时候，突然就发现是不是真正的成长了，好像并没有那么重要了；然后到了高中，觉得非要吐露出自己的心声

31、才能为高中生涯里的懵懂情愫划上一个句点，但毕业晚会的时候最终还是被梗塞在了咽喉，后来再次站在他曾经挥汗如雨的球场，看着他投过篮球的球框时，突然间发现自己已经想不起他的容颜。Originally, this world, can produce a chemical reaction to an event, in addition to resolutely, have to do, and time.原来，这个世界上，对某个事件能产生化学反应的，除了非做不可的坚决，还有，时间。A persons time, your ideas are always special to clear. Wa

32、nt, want, line is clear, as if nothing could shake his. Also once seemed to be determined to do something, but more often is he backed out at last. Dislike his cowardice, finally found that there are a lot of love, there are a lot of miss, like shadow really have been doomed. Those who do, just gree

33、n years oneself give oneself an arm injection, or is a self-righteous spiritual.一个人的时候，自己的想法总是特别地清晰。想要的，不想要的，界限明确，好像没有什么可以撼动自己。也曾经好像已经下定了决心去做某件事，但更多的时候是最后又打起了退堂鼓。嫌恶过自己的怯懦，最终却发现有很多缘分，有很多错过，好像冥冥之中真的已经注定。那些曾经所谓的非做不可，只是青葱年华里自己给自己注射的一支强心剂，或者说，是自以为是的精神寄托罢了。At the moment, the sky is dark, the air is fresh

34、factor after just rained. Suddenly thought of blue plaid shirt; Those were broken into various shapes of stationery; From the corner at the beginning of deep friendship; Have declared the end of the encounter that havent start planning. Those years, those days of do, finally, like youth, will end in

35、 our life.此刻，天空是阴暗的，空气里有着刚下过雨之后的清新因子。突然想到那件蓝格子衬衫；那些被折成各种各样形状的信纸；那段从街角深巷伊始的友谊；还有那场还没有开始就宣告了终结的邂逅计划那些年那些天的非做不可，终于和青春一样，都将在我们的人生中谢幕。Baumgartner the disappointing news: Mission aborted. r plays an important role in this mission. Starting at the ground, conditions have to be very calm - winds less than 2

36、 mph, with no precipitation or humidity and limited cloud cover. The balloon, with capsule attached, will move through the lower level of the atmosphere (the troposphere) where our day-to-day weather lives. It will climb higher than the tip of Mount Everest (5.5 miles/8.85 kilometers), drifting even

37、 higher than the cruising altitude of commercial airliners (5.6 miles/9.17 kilometers) and into the stratosphere. As he crosses the boundary layer (called the tropopause),e can expect a lot of turbulence.The supersonic descent could happen as early as Sunda.The weatheThe balloon will slowly drift to

38、 the edge of space at 120,000 feet ( Then, I would assume, he will slowly step out onto something resembling an Olympic diving platform.Below, the Earth becomes the concrete bottom of a swimming pool that he wants to land on, but not too hard. Still, hell be traveling fast, so despite the distance,

39、it will not be like diving into the deep end of a pool. It will be like he is diving into the shallow end. Skydiver preps for the big jumpWhen he jumps, he is expected to reach the speed of sound - 690 mph (1,110 kph) - in less than 40 seconds. Like hitting the top of the water, he will begin to slo

40、w as he approaches the more dense air closer to Earth. But this will not be enough to stop him completely.If he goes too fast or spins out of control, he has a stabilization parachute that can be deployed to slow him down. His team hopes its not needed. Instead, he plans to deploy his 270-square-foo

41、t (25-square-meter) main chute at an altitude of around 5,000 feet (1,524 meters).In order to deploy this chute successfully, he will have to slow to 172 mph (277 kph). He will have a reserve parachute that will open automatically if he loses consciousness at mach speeds.Even if everything goes as planned, it wont. Baumgartner still will free fall at a speed that would cause you and me to pass out, and no parachute is guaranteed to work higher than 25,000 feet (7,620 meters).cause there13