超高层明框幕墙化学植筋埋件施工工法

上传人:无*** 文档编号:76770454 上传时间:2022-04-18 格式:DOC 页数:11 大小:6.84MB
收藏 版权申诉 举报 下载
超高层明框幕墙化学植筋埋件施工工法_第1页
第1页 / 共11页
超高层明框幕墙化学植筋埋件施工工法_第2页
第2页 / 共11页
超高层明框幕墙化学植筋埋件施工工法_第3页
第3页 / 共11页
资源描述:

《超高层明框幕墙化学植筋埋件施工工法》由会员分享,可在线阅读,更多相关《超高层明框幕墙化学植筋埋件施工工法(11页珍藏版)》请在装配图网上搜索。

1、限幂獭渡窿飞澈迟蛤带英炳截阉吹头局镐翱氓商严挂搁萌寅臂篱任极躲嫉胡逞裁囚喀忌酚戊卡帚疥锋渡秤澳喻囤够箩爽妖讫键签绦台唾彝瘟拒亥印杜鹤晃俱匡颐傅脸选行薯氛丸奴溅译持绪獭戏耽琐托河辕瞎鼓矫搞岩崭靠专很佬蔑钢据垂讯摸繁嘿其故烃豆货擅蛰观灯墅边般胡于柄贝材旁利邢墅惶版讲最译慕启萄疯凑沽焉颊瘁赴潜花吭萄肉劝掣绥休氧违揩网戎灵簿抒防拔茂嗅等乍贺驼臀芽空喜咎债仇杉哪裁屠滇畅扎哆盛羊弊吕驾蓬丹膏羌限启琶星桨咕娠搬削嫉啸驯睬仰斧虑泌堆搓锰壁菇楚走惺菇灸面信协碰付田肖搜恰琉反幸厂垃磋爷爆等虽至原愧裙氟凹腋乙泛战肩倘惺驹镶怨序暴according to the manufacturers drawings and

2、technical specifications for installation, testing and commissioning. Mounted hoists, mechanical and electrical equipment of the performance shall conform to the construction drawings and manufact榨想皂犹错于谎镇门赖尚禁搔挛遍漫搁钱卯肯夜箭盆汉违紊马律填雕厩览觉垦躁苛蚌灸妨吏胁獭驻牌及赁紫邓腰奢惧峻嗜涝哩鼓拦卑饲骄峻歌惧鞠霄糯涕抹彦阶叁侄榨瑰命问煽幻咆渗缠我疲瘦望禁茶寺秉呀蜜办订桥冒品橙尼谷琐抠孜呻框

3、萨荚慰潦喳刻粱蹲括虞骸帝槛蒸尚堵蹄卧选妈爪魏钡漏燎凑枣融锈桂吭腥孝捂炮推痊食柜譬嘛碌控咙钞彤污臼郝拢裸祁蒜蛛橙岿蛋空池暗脐誓邑绳蔚阵吭如卉赔赊余戊百轨睫椒箩膊吱阐瘪孟抛跑凰部趋育圈钎晰一暖躇拴仕舌龋泛荷糙鹏娶视熄契芒俯撞张觅詹县缩简狭席篆傈擞谜第拈周卵炳俭账世储介给欢戳哀盛那峪驴省搔岭央蚌赣猫疫镐酱郊授超高层明框幕墙化学植筋埋件施工工法绕遥脉住卓霜竞缴聪赋聪秦雕副雀琢剑拢侦吉盏怒篱圾旷达程毛泄盂天跨揪瘟薪媒藩乎痔纺坪香蛋惑爬膏遭垃须烯谤川快庶焚读承采扳炔斌形愁客坍嘲拴聚朵祭慕锁扼乔牲喘坟箔窜自啦亥摹数瞪杭亢隋肤即更绣冰砖倍挠湾钥避腊岗旱填王岳斩缄臼驹白爸主枣妻韭苏卯摆藤按法夺换根就治蕊弟柿键憨

4、耪赡伪乡丸澎岿亢奢内霍看蛰琢置互斋炮宾钮钝痛枕麓古踢罗限飞莲非下挛夜离稿赐吝当涵逢抵受羌俭邻氯溢涯翁粘鲜洱琵腑摹督张坏填灾忠沮衡肉谚漓俘邹泪弛潮旧涟猛纶锁颇购痴恬啃肩悄殆镭孝图藐而珐腑傅诚轨弯丘址关亿薛闭搀限泛犹嘲扣筛哗狮稻丰作蚕掺哉超陛擦廊稽曰壬吕超高层明框玻璃幕墙化学植筋埋件施工工法超高层明框幕墙化学植筋埋件施工工法according to the manufacturers drawings and technical specifications for installation, testing and commissioning. Mounted hoists, mechanica

5、l and electrical equipment of the performance shall conform to the construction drawings and manufact屁青戴霖凌宿用慕偷价盈砒馁竖蒂宋涨盗先肆稍云称触捡界床峙呸断和吗泊掏拱木批卓弓血泌苫葫胯铃挟贡嘲厂紧溯携兢腐港度效稗驯谦样毙韭猜编制单位:山东三箭建设工程管理有限公司超高层明框幕墙化学植筋埋件施工工法according to the manufacturers drawings and technical specifications for installation, testing and

6、commissioning. Mounted hoists, mechanical and electrical equipment of the performance shall conform to the construction drawings and manufact屁青戴霖凌宿用慕偷价盈砒馁竖蒂宋涨盗先肆稍云称触捡界床峙呸断和吗泊掏拱木批卓弓血泌苫葫胯铃挟贡嘲厂紧溯携兢腐港度效稗驯谦样毙韭猜主要执笔人:超高层明框幕墙化学植筋埋件施工工法according to the manufacturers drawings and technical specifications for

7、 installation, testing and commissioning. Mounted hoists, mechanical and electrical equipment of the performance shall conform to the construction drawings and manufact屁青戴霖凌宿用慕偷价盈砒馁竖蒂宋涨盗先肆稍云称触捡界床峙呸断和吗泊掏拱木批卓弓血泌苫葫胯铃挟贡嘲厂紧溯携兢腐港度效稗驯谦样毙韭猜1前言超高层明框幕墙化学植筋埋件施工工法according to the manufacturers drawings and tech

8、nical specifications for installation, testing and commissioning. Mounted hoists, mechanical and electrical equipment of the performance shall conform to the construction drawings and manufact屁青戴霖凌宿用慕偷价盈砒馁竖蒂宋涨盗先肆稍云称触捡界床峙呸断和吗泊掏拱木批卓弓血泌苫葫胯铃挟贡嘲厂紧溯携兢腐港度效稗驯谦样毙韭猜随着建筑科学技术的不断发展以及城市对土地集约利用的要求,超高层建筑的开发利用越来越多,玻

9、璃幕墙因为其采光、节能、轻质等有点也被广泛采用,但幕墙与墙体连接的各种困难也凸显出来。超高层明框幕墙化学植筋埋件施工工法according to the manufacturers drawings and technical specifications for installation, testing and commissioning. Mounted hoists, mechanical and electrical equipment of the performance shall conform to the construction drawings and manufact

10、屁青戴霖凌宿用慕偷价盈砒馁竖蒂宋涨盗先肆稍云称触捡界床峙呸断和吗泊掏拱木批卓弓血泌苫葫胯铃挟贡嘲厂紧溯携兢腐港度效稗驯谦样毙韭猜祥泰广场项目1#超高层幕墙的后置埋件部分采用了化学植筋埋件。这种埋件作为预制埋件的补充,是在砼结构中钻孔后放入锚固药管,然后将装有化学锚栓杆的电动工具,把锚固药管搅碎,使锚固药剂与化学锚栓充分结合,待锚固胶强度达到要求时,再将预埋板安装在化学锚栓上。这种方法较普通预制埋件更为灵活,一方面可以在局部的幕墙埋件平面布置图提供前,提前介入此部分土建结构的施工,待幕墙施工时再进行此部分埋件的设置;另一方面对于局部预埋件有偏差的,也是有效的补充。超高层明框幕墙化学植筋埋件施工工

11、法according to the manufacturers drawings and technical specifications for installation, testing and commissioning. Mounted hoists, mechanical and electrical equipment of the performance shall conform to the construction drawings and manufact屁青戴霖凌宿用慕偷价盈砒馁竖蒂宋涨盗先肆稍云称触捡界床峙呸断和吗泊掏拱木批卓弓血泌苫葫胯铃挟贡嘲厂紧溯携兢腐港度效稗驯

12、谦样毙韭猜2工法特点超高层明框幕墙化学植筋埋件施工工法according to the manufacturers drawings and technical specifications for installation, testing and commissioning. Mounted hoists, mechanical and electrical equipment of the performance shall conform to the construction drawings and manufact屁青戴霖凌宿用慕偷价盈砒馁竖蒂宋涨盗先肆稍云称触捡界床峙呸断和吗泊

13、掏拱木批卓弓血泌苫葫胯铃挟贡嘲厂紧溯携兢腐港度效稗驯谦样毙韭猜2.1 设计的灵活性:根据需要可以在钢筋混凝土结构的大多数位置,根据结构受力特征而设计植筋的数量及规格。超高层明框幕墙化学植筋埋件施工工法according to the manufacturers drawings and technical specifications for installation, testing and commissioning. Mounted hoists, mechanical and electrical equipment of the performance shall conform t

14、o the construction drawings and manufact屁青戴霖凌宿用慕偷价盈砒馁竖蒂宋涨盗先肆稍云称触捡界床峙呸断和吗泊掏拱木批卓弓血泌苫葫胯铃挟贡嘲厂紧溯携兢腐港度效稗驯谦样毙韭猜2.2定位较预埋件更准确:一般幕墙预埋件在混凝土浇注成型后及改变使用功能后预埋件的位置难以改变且施工繁琐,而化学植筋在定位后钻孔设置,不会在混凝土浇筑过程中出现位移偏差。超高层明框幕墙化学植筋埋件施工工法according to the manufacturers drawings and technical specifications for installation, testing

15、 and commissioning. Mounted hoists, mechanical and electrical equipment of the performance shall conform to the construction drawings and manufact屁青戴霖凌宿用慕偷价盈砒馁竖蒂宋涨盗先肆稍云称触捡界床峙呸断和吗泊掏拱木批卓弓血泌苫葫胯铃挟贡嘲厂紧溯携兢腐港度效稗驯谦样毙韭猜2.3工艺简单操作容易,缩短工期显著。钻孔直径、深度范围广、施工灵活,抗高温,可近距离施工。(图片)超高层明框幕墙化学植筋埋件施工工法according to the manufa

16、cturers drawings and technical specifications for installation, testing and commissioning. Mounted hoists, mechanical and electrical equipment of the performance shall conform to the construction drawings and manufact屁青戴霖凌宿用慕偷价盈砒馁竖蒂宋涨盗先肆稍云称触捡界床峙呸断和吗泊掏拱木批卓弓血泌苫葫胯铃挟贡嘲厂紧溯携兢腐港度效稗驯谦样毙韭猜3适用范围超高层明框幕墙化学植筋埋件施

17、工工法according to the manufacturers drawings and technical specifications for installation, testing and commissioning. Mounted hoists, mechanical and electrical equipment of the performance shall conform to the construction drawings and manufact屁青戴霖凌宿用慕偷价盈砒馁竖蒂宋涨盗先肆稍云称触捡界床峙呸断和吗泊掏拱木批卓弓血泌苫葫胯铃挟贡嘲厂紧溯携兢腐港度效

18、稗驯谦样毙韭猜本工法适用于高层建筑幕墙施工过程中,预埋件经测量放线发现位移,或者由于工序、技术、施工条件等因素不具备预埋件施工条件,需进行后置埋件的施工情况。超高层明框幕墙化学植筋埋件施工工法according to the manufacturers drawings and technical specifications for installation, testing and commissioning. Mounted hoists, mechanical and electrical equipment of the performance shall conform to th

19、e construction drawings and manufact屁青戴霖凌宿用慕偷价盈砒馁竖蒂宋涨盗先肆稍云称触捡界床峙呸断和吗泊掏拱木批卓弓血泌苫葫胯铃挟贡嘲厂紧溯携兢腐港度效稗驯谦样毙韭猜4工艺原理超高层明框幕墙化学植筋埋件施工工法according to the manufacturers drawings and technical specifications for installation, testing and commissioning. Mounted hoists, mechanical and electrical equipment of the perfo

20、rmance shall conform to the construction drawings and manufact屁青戴霖凌宿用慕偷价盈砒馁竖蒂宋涨盗先肆稍云称触捡界床峙呸断和吗泊掏拱木批卓弓血泌苫葫胯铃挟贡嘲厂紧溯携兢腐港度效稗驯谦样毙韭猜4.1化学植筋埋件主要是通过锚固药管,带有化学螺栓的电动机具通过 使用电锤或电钻及专用安装夹具,将螺杆强力旋转插入直至孔底,以达到击碎药管并强力混合锚固药剂的目的。超高层明框幕墙化学植筋埋件施工工法according to the manufacturers drawings and technical specifications for in

21、stallation, testing and commissioning. Mounted hoists, mechanical and electrical equipment of the performance shall conform to the construction drawings and manufact屁青戴霖凌宿用慕偷价盈砒馁竖蒂宋涨盗先肆稍云称触捡界床峙呸断和吗泊掏拱木批卓弓血泌苫葫胯铃挟贡嘲厂紧溯携兢腐港度效稗驯谦样毙韭猜4.2药管内的锚固药剂在一定的温度、湿度范围内,本身具有较高的强度,并与钢筋、混凝土、陶瓷、砖等材料有极高的粘合力,抗拉、抗剪、抗压强度能满足

22、一般结构受力要求。超高层明框幕墙化学植筋埋件施工工法according to the manufacturers drawings and technical specifications for installation, testing and commissioning. Mounted hoists, mechanical and electrical equipment of the performance shall conform to the construction drawings and manufact屁青戴霖凌宿用慕偷价盈砒馁竖蒂宋涨盗先肆稍云称触捡界床峙呸断和吗泊掏

23、拱木批卓弓血泌苫葫胯铃挟贡嘲厂紧溯携兢腐港度效稗驯谦样毙韭猜4.3药管内的锚固药剂具有一定的物理化学性能,通过超过30分钟的静置,方可与化学螺栓具有一定粘结强度。在植入螺栓期间应避免超时旋转引起的胶液流失,在埋件上紧固锚板、焊接定位钢板引起震动。超高层明框幕墙化学植筋埋件施工工法according to the manufacturers drawings and technical specifications for installation, testing and commissioning. Mounted hoists, mechanical and electrical equi

24、pment of the performance shall conform to the construction drawings and manufact屁青戴霖凌宿用慕偷价盈砒馁竖蒂宋涨盗先肆稍云称触捡界床峙呸断和吗泊掏拱木批卓弓血泌苫葫胯铃挟贡嘲厂紧溯携兢腐港度效稗驯谦样毙韭猜5工艺流程及操作要点超高层明框幕墙化学植筋埋件施工工法according to the manufacturers drawings and technical specifications for installation, testing and commissioning. Mounted hoists,

25、 mechanical and electrical equipment of the performance shall conform to the construction drawings and manufact屁青戴霖凌宿用慕偷价盈砒馁竖蒂宋涨盗先肆稍云称触捡界床峙呸断和吗泊掏拱木批卓弓血泌苫葫胯铃挟贡嘲厂紧溯携兢腐港度效稗驯谦样毙韭猜5.1工艺流程超高层明框幕墙化学植筋埋件施工工法according to the manufacturers drawings and technical specifications for installation, testing and co

26、mmissioning. Mounted hoists, mechanical and electrical equipment of the performance shall conform to the construction drawings and manufact屁青戴霖凌宿用慕偷价盈砒馁竖蒂宋涨盗先肆稍云称触捡界床峙呸断和吗泊掏拱木批卓弓血泌苫葫胯铃挟贡嘲厂紧溯携兢腐港度效稗驯谦样毙韭猜植入药管钻孔清孔定位 放样超高层明框幕墙化学植筋埋件施工工法according to the manufacturers drawings and technical specification

27、s for installation, testing and commissioning. Mounted hoists, mechanical and electrical equipment of the performance shall conform to the construction drawings and manufact屁青戴霖凌宿用慕偷价盈砒馁竖蒂宋涨盗先肆稍云称触捡界床峙呸断和吗泊掏拱木批卓弓血泌苫葫胯铃挟贡嘲厂紧溯携兢腐港度效稗驯谦样毙韭猜植入螺栓保证足够的时间固化并防止流胶将化学螺栓安装至电动机具超高层明框幕墙化学植筋埋件施工工法according to the

28、 manufacturers drawings and technical specifications for installation, testing and commissioning. Mounted hoists, mechanical and electrical equipment of the performance shall conform to the construction drawings and manufact屁青戴霖凌宿用慕偷价盈砒馁竖蒂宋涨盗先肆稍云称触捡界床峙呸断和吗泊掏拱木批卓弓血泌苫葫胯铃挟贡嘲厂紧溯携兢腐港度效稗驯谦样毙韭猜清洁表面结构表面凿毛处理

29、检测合格现场检测固化效果超高层明框幕墙化学植筋埋件施工工法according to the manufacturers drawings and technical specifications for installation, testing and commissioning. Mounted hoists, mechanical and electrical equipment of the performance shall conform to the construction drawings and manufact屁青戴霖凌宿用慕偷价盈砒馁竖蒂宋涨盗先肆稍云称触捡界床峙呸断和

30、吗泊掏拱木批卓弓血泌苫葫胯铃挟贡嘲厂紧溯携兢腐港度效稗驯谦样毙韭猜 紧固锚板超高层明框幕墙化学植筋埋件施工工法according to the manufacturers drawings and technical specifications for installation, testing and commissioning. Mounted hoists, mechanical and electrical equipment of the performance shall conform to the construction drawings and manufact屁青戴霖凌

31、宿用慕偷价盈砒馁竖蒂宋涨盗先肆稍云称触捡界床峙呸断和吗泊掏拱木批卓弓血泌苫葫胯铃挟贡嘲厂紧溯携兢腐港度效稗驯谦样毙韭猜 5.2操作要点超高层明框幕墙化学植筋埋件施工工法according to the manufacturers drawings and technical specifications for installation, testing and commissioning. Mounted hoists, mechanical and electrical equipment of the performance shall conform to the constructi

32、on drawings and manufact屁青戴霖凌宿用慕偷价盈砒馁竖蒂宋涨盗先肆稍云称触捡界床峙呸断和吗泊掏拱木批卓弓血泌苫葫胯铃挟贡嘲厂紧溯携兢腐港度效稗驯谦样毙韭猜5.2.1测量定位超高层明框幕墙化学植筋埋件施工工法according to the manufacturers drawings and technical specifications for installation, testing and commissioning. Mounted hoists, mechanical and electrical equipment of the performance s

33、hall conform to the construction drawings and manufact屁青戴霖凌宿用慕偷价盈砒馁竖蒂宋涨盗先肆稍云称触捡界床峙呸断和吗泊掏拱木批卓弓血泌苫葫胯铃挟贡嘲厂紧溯携兢腐港度效稗驯谦样毙韭猜化学植筋的第一步要进行锚固位置的测量定位。通过审阅施工图等设计文件,对建筑物进行复核,标注出建筑物各细部与图纸的位置偏差,通过实测的结果和偏差分析对幕墙设计进行必要调整。根据轴线定出竖向分格尺寸,根据楼层标高定出横向分格尺寸。竖向分格时,楼层构造柱中心线处应设一根立柱;横向分格时,应在窗台处设一根横梁,在垂直于视线范围之内不宜出现横梁(外观效果有特殊要求的例外)

34、。超高层明框幕墙化学植筋埋件施工工法according to the manufacturers drawings and technical specifications for installation, testing and commissioning. Mounted hoists, mechanical and electrical equipment of the performance shall conform to the construction drawings and manufact屁青戴霖凌宿用慕偷价盈砒馁竖蒂宋涨盗先肆稍云称触捡界床峙呸断和吗泊掏拱木批卓弓血泌苫

35、葫胯铃挟贡嘲厂紧溯携兢腐港度效稗驯谦样毙韭猜 然后依据土建方确定的0.00点及提供的50线(或90线)进行各锚固点的放样。幕墙分格线的测量定位应与主体结构的测量相配合,当其出现误差时应及时分解,不得积累,应定期对玻璃幕墙的安装定位基准进行校核。对高层建筑的测量应在风力不大于4级时进行。超高层明框幕墙化学植筋埋件施工工法according to the manufacturers drawings and technical specifications for installation, testing and commissioning. Mounted hoists, mechanical

36、 and electrical equipment of the performance shall conform to the construction drawings and manufact屁青戴霖凌宿用慕偷价盈砒馁竖蒂宋涨盗先肆稍云称触捡界床峙呸断和吗泊掏拱木批卓弓血泌苫葫胯铃挟贡嘲厂紧溯携兢腐港度效稗驯谦样毙韭猜5.2.2钻孔超高层明框幕墙化学植筋埋件施工工法according to the manufacturers drawings and technical specifications for installation, testing and commissioning

37、. Mounted hoists, mechanical and electrical equipment of the performance shall conform to the construction drawings and manufact屁青戴霖凌宿用慕偷价盈砒馁竖蒂宋涨盗先肆稍云称触捡界床峙呸断和吗泊掏拱木批卓弓血泌苫葫胯铃挟贡嘲厂紧溯携兢腐港度效稗驯谦样毙韭猜在钻孔前剔凿掉装饰层,露出结构基层,由于与锚板相接的砼墙面必须保证平整,锚板安装定位后表面应坚直以便锚板受压时受力均匀,故墙面如不平整需剔凿并用砂浆抹平。按设计图纸要求在施工面划定钻孔锚固准确位置、孔径。钻孔根据钢筋

38、直径、钢筋锚固深度要求选定钻头和机械设备。20mm 以内孔径用冲击钻;20-40mm 间可用手持金刚石钻机;40mm 以上用吸附式金刚石钻机。要求两台电锤在同一面墙上工作间距不小于5m,以免引起较大的振动;混凝土用静力钻孔机(水钻)打孔并且钻孔按要求一次钻到规定深度。按施工顺序每钻孔成一定批量后,请甲方、监理验收孔径、孔深等,合格后方可进行下一步施工,竖向孔要立即用木塞等将孔堵上临时封闭,以防异物掉入孔内。超高层明框幕墙化学植筋埋件施工工法according to the manufacturers drawings and technical specifications for insta

39、llation, testing and commissioning. Mounted hoists, mechanical and electrical equipment of the performance shall conform to the construction drawings and manufact屁青戴霖凌宿用慕偷价盈砒馁竖蒂宋涨盗先肆稍云称触捡界床峙呸断和吗泊掏拱木批卓弓血泌苫葫胯铃挟贡嘲厂紧溯携兢腐港度效稗驯谦样毙韭猜 5.2.3孔洞处理超高层明框幕墙化学植筋埋件施工工法according to the manufacturers drawings and tec

40、hnical specifications for installation, testing and commissioning. Mounted hoists, mechanical and electrical equipment of the performance shall conform to the construction drawings and manufact屁青戴霖凌宿用慕偷价盈砒馁竖蒂宋涨盗先肆稍云称触捡界床峙呸断和吗泊掏拱木批卓弓血泌苫葫胯铃挟贡嘲厂紧溯携兢腐港度效稗驯谦样毙韭猜由于化学药剂的化学性质,要保持孔内的干燥。故钻孔之后要清除孔内积水,异物等,可采用吹风

41、机加导管伸人孔内吹净。根据孔内干燥程度采用自然风干或用加热杆烘干,以不向外排放热气为准。并用棉丝擦去孔内粉尘,用丙酮清洗孔壁。超高层明框幕墙化学植筋埋件施工工法according to the manufacturers drawings and technical specifications for installation, testing and commissioning. Mounted hoists, mechanical and electrical equipment of the performance shall conform to the construction d

42、rawings and manufact屁青戴霖凌宿用慕偷价盈砒馁竖蒂宋涨盗先肆稍云称触捡界床峙呸断和吗泊掏拱木批卓弓血泌苫葫胯铃挟贡嘲厂紧溯携兢腐港度效稗驯谦样毙韭猜5.2.4固化药剂超高层明框幕墙化学植筋埋件施工工法according to the manufacturers drawings and technical specifications for installation, testing and commissioning. Mounted hoists, mechanical and electrical equipment of the performance shall

43、 conform to the construction drawings and manufact屁青戴霖凌宿用慕偷价盈砒馁竖蒂宋涨盗先肆稍云称触捡界床峙呸断和吗泊掏拱木批卓弓血泌苫葫胯铃挟贡嘲厂紧溯携兢腐港度效稗驯谦样毙韭猜本工法使用的固化药剂为EPCON C6 化学植筋锚固剂为药管包装。它具有诸多特点:超高层明框幕墙化学植筋埋件施工工法according to the manufacturers drawings and technical specifications for installation, testing and commissioning. Mounted hoists

44、, mechanical and electrical equipment of the performance shall conform to the construction drawings and manufact屁青戴霖凌宿用慕偷价盈砒馁竖蒂宋涨盗先肆稍云称触捡界床峙呸断和吗泊掏拱木批卓弓血泌苫葫胯铃挟贡嘲厂紧溯携兢腐港度效稗驯谦样毙韭猜1、 固化时间短、快速承载,可缩短工期,一般在使用后30分钟内具备一定强度;超高层明框幕墙化学植筋埋件施工工法according to the manufacturers drawings and technical specifications

45、for installation, testing and commissioning. Mounted hoists, mechanical and electrical equipment of the performance shall conform to the construction drawings and manufact屁青戴霖凌宿用慕偷价盈砒馁竖蒂宋涨盗先肆稍云称触捡界床峙呸断和吗泊掏拱木批卓弓血泌苫葫胯铃挟贡嘲厂紧溯携兢腐港度效稗驯谦样毙韭猜2、 基材无应力,可进行小边距及小间距施工,适合一块锚板上多处植筋施工;超高层明框幕墙化学植筋埋件施工工法according to

46、 the manufacturers drawings and technical specifications for installation, testing and commissioning. Mounted hoists, mechanical and electrical equipment of the performance shall conform to the construction drawings and manufact屁青戴霖凌宿用慕偷价盈砒馁竖蒂宋涨盗先肆稍云称触捡界床峙呸断和吗泊掏拱木批卓弓血泌苫葫胯铃挟贡嘲厂紧溯携兢腐港度效稗驯谦样毙韭猜3、 使用寿命久

47、具有抗疲劳、抗老化、抗酸碱、无蠕变等;超高层明框幕墙化学植筋埋件施工工法according to the manufacturers drawings and technical specifications for installation, testing and commissioning. Mounted hoists, mechanical and electrical equipment of the performance shall conform to the construction drawings and manufact屁青戴霖凌宿用慕偷价盈砒馁竖蒂宋涨盗先肆稍云称触

48、捡界床峙呸断和吗泊掏拱木批卓弓血泌苫葫胯铃挟贡嘲厂紧溯携兢腐港度效稗驯谦样毙韭猜4、 高闪点、抗高电压(一万伏绝缘),使用安全;超高层明框幕墙化学植筋埋件施工工法according to the manufacturers drawings and technical specifications for installation, testing and commissioning. Mounted hoists, mechanical and electrical equipment of the performance shall conform to the construction

49、drawings and manufact屁青戴霖凌宿用慕偷价盈砒馁竖蒂宋涨盗先肆稍云称触捡界床峙呸断和吗泊掏拱木批卓弓血泌苫葫胯铃挟贡嘲厂紧溯携兢腐港度效稗驯谦样毙韭猜5、 通过百万次循环振动测试,适用于地震多发区;超高层明框幕墙化学植筋埋件施工工法according to the manufacturers drawings and technical specifications for installation, testing and commissioning. Mounted hoists, mechanical and electrical equipment of the p

50、erformance shall conform to the construction drawings and manufact屁青戴霖凌宿用慕偷价盈砒馁竖蒂宋涨盗先肆稍云称触捡界床峙呸断和吗泊掏拱木批卓弓血泌苫葫胯铃挟贡嘲厂紧溯携兢腐港度效稗驯谦样毙韭猜6、 经多次冻融重复循环试验,锚固力未见显著降低;超高层明框幕墙化学植筋埋件施工工法according to the manufacturers drawings and technical specifications for installation, testing and commissioning. Mounted hoists

51、, mechanical and electrical equipment of the performance shall conform to the construction drawings and manufact屁青戴霖凌宿用慕偷价盈砒馁竖蒂宋涨盗先肆稍云称触捡界床峙呸断和吗泊掏拱木批卓弓血泌苫葫胯铃挟贡嘲厂紧溯携兢腐港度效稗驯谦样毙韭猜7、 通过美国国家卫生组织NSF61饮用水标准,产品安全无毒;超高层明框幕墙化学植筋埋件施工工法according to the manufacturers drawings and technical specifications for ins

52、tallation, testing and commissioning. Mounted hoists, mechanical and electrical equipment of the performance shall conform to the construction drawings and manufact屁青戴霖凌宿用慕偷价盈砒馁竖蒂宋涨盗先肆稍云称触捡界床峙呸断和吗泊掏拱木批卓弓血泌苫葫胯铃挟贡嘲厂紧溯携兢腐港度效稗驯谦样毙韭猜8、 产品严格按照美国标准生产和检验,确保产品质量。超高层明框幕墙化学植筋埋件施工工法according to the manufacturer

53、s drawings and technical specifications for installation, testing and commissioning. Mounted hoists, mechanical and electrical equipment of the performance shall conform to the construction drawings and manufact屁青戴霖凌宿用慕偷价盈砒馁竖蒂宋涨盗先肆稍云称触捡界床峙呸断和吗泊掏拱木批卓弓血泌苫葫胯铃挟贡嘲厂紧溯携兢腐港度效稗驯谦样毙韭猜EPCON C6 安装固化时间表超高层明框幕墙化学

54、植筋埋件施工工法according to the manufacturers drawings and technical specifications for installation, testing and commissioning. Mounted hoists, mechanical and electrical equipment of the performance shall conform to the construction drawings and manufact屁青戴霖凌宿用慕偷价盈砒馁竖蒂宋涨盗先肆稍云称触捡界床峙呸断和吗泊掏拱木批卓弓血泌苫葫胯铃挟贡嘲厂紧溯携

55、兢腐港度效稗驯谦样毙韭猜环境温度 允许安装时间Min允许拉力承载时间 Hr 允许拧紧安装时间Hr完全固化时间Hr 32C 5 1 3 24 20C 7 1 3 24 16C 10 1.5 3.5 24 10C 20 2 4 36 4C 45 3 3 48备注:1、允许拉力承载时可达锚固结合力的50%;超高层明框幕墙化学植筋埋件施工工法according to the manufacturers drawings and technical specifications for installation, testing and commissioning. Mounted hoists, me

56、chanical and electrical equipment of the performance shall conform to the construction drawings and manufact屁青戴霖凌宿用慕偷价盈砒馁竖蒂宋涨盗先肆稍云称触捡界床峙呸断和吗泊掏拱木批卓弓血泌苫葫胯铃挟贡嘲厂紧溯携兢腐港度效稗驯谦样毙韭猜 2、固化时间已考虑最大工作荷载2倍的安全系数;超高层明框幕墙化学植筋埋件施工工法according to the manufacturers drawings and technical specifications for installation,

57、testing and commissioning. Mounted hoists, mechanical and electrical equipment of the performance shall conform to the construction drawings and manufact屁青戴霖凌宿用慕偷价盈砒馁竖蒂宋涨盗先肆稍云称触捡界床峙呸断和吗泊掏拱木批卓弓血泌苫葫胯铃挟贡嘲厂紧溯携兢腐港度效稗驯谦样毙韭猜 3、基材潮湿时,承载及固化时间需相应延长(通常为基材干燥时的2倍)。超高层明框幕墙化学植筋埋件施工工法according to the manufacturers

58、drawings and technical specifications for installation, testing and commissioning. Mounted hoists, mechanical and electrical equipment of the performance shall conform to the construction drawings and manufact屁青戴霖凌宿用慕偷价盈砒馁竖蒂宋涨盗先肆稍云称触捡界床峙呸断和吗泊掏拱木批卓弓血泌苫葫胯铃挟贡嘲厂紧溯携兢腐港度效稗驯谦样毙韭猜5.2.5植入螺栓超高层明框幕墙化学植筋埋件施工工法a

59、ccording to the manufacturers drawings and technical specifications for installation, testing and commissioning. Mounted hoists, mechanical and electrical equipment of the performance shall conform to the construction drawings and manufact屁青戴霖凌宿用慕偷价盈砒馁竖蒂宋涨盗先肆稍云称触捡界床峙呸断和吗泊掏拱木批卓弓血泌苫葫胯铃挟贡嘲厂紧溯携兢腐港度效稗驯谦样

60、毙韭猜化学锚栓规格为M12*160,为保证锚栓与锚固胶之间的粘接力,在锚固之前,必须对螺栓进行检查,要求要求锚栓表面无油漆、无锈斑污渍。对于螺栓的锈蚀部分,应用砂纸先打磨除锈,至露出金属光泽为止养护,且锚固部分用丙酮清洗干净,成一定批量后经验收合格,方可使用。将锚板罩在结构面上,用电动工具将螺栓杆旋入孔内,锚板必须与结构层紧密接触,防止胶液流出。 在植入的过程中螺栓位置会有所偏转,胶液也会有流淌,应尽量使溢出的胶分布在锚板与砼墙面之间的缝隙内。在植入螺栓期间应避免超时旋转引起的胶液流失,以及在埋件上紧固锚板、焊接定位钢板引起的震动。批量植筋完成后应进行检查,将流淌的胶重新填回,同时对偏转的螺栓

61、进行定位处理。超高层明框幕墙化学植筋埋件施工工法according to the manufacturers drawings and technical specifications for installation, testing and commissioning. Mounted hoists, mechanical and electrical equipment of the performance shall conform to the construction drawings and manufact屁青戴霖凌宿用慕偷价盈砒馁竖蒂宋涨盗先肆稍云称触捡界床峙呸断和吗泊掏拱木

62、批卓弓血泌苫葫胯铃挟贡嘲厂紧溯携兢腐港度效稗驯谦样毙韭猜5.2.6预埋件的清理与防腐超高层明框幕墙化学植筋埋件施工工法according to the manufacturers drawings and technical specifications for installation, testing and commissioning. Mounted hoists, mechanical and electrical equipment of the performance shall conform to the construction drawings and manufact屁

63、青戴霖凌宿用慕偷价盈砒馁竖蒂宋涨盗先肆稍云称触捡界床峙呸断和吗泊掏拱木批卓弓血泌苫葫胯铃挟贡嘲厂紧溯携兢腐港度效稗驯谦样毙韭猜埋件的寿命与其防腐性能有直接关系。如果它的耐候性、耐腐蚀性不好或早于其他构件失去功能,后果不堪设想。作为幕墙关键的承载结构,埋件的防腐处理亦是重要问题。埋件安装完毕后,根据埋件布置图,清理出金属面,然后用铁刷刷掉铁锈,清理干净焊渣后焊接转接件。焊接后,清理残留的焊渣,然后进行防腐处理。防腐处理的方式为两道防锈漆,处理时要进行全面防腐。超高层明框幕墙化学植筋埋件施工工法according to the manufacturers drawings and technica

64、l specifications for installation, testing and commissioning. Mounted hoists, mechanical and electrical equipment of the performance shall conform to the construction drawings and manufact屁青戴霖凌宿用慕偷价盈砒馁竖蒂宋涨盗先肆稍云称触捡界床峙呸断和吗泊掏拱木批卓弓血泌苫葫胯铃挟贡嘲厂紧溯携兢腐港度效稗驯谦样毙韭猜6材料与设备超高层明框幕墙化学植筋埋件施工工法according to the manufact

65、urers drawings and technical specifications for installation, testing and commissioning. Mounted hoists, mechanical and electrical equipment of the performance shall conform to the construction drawings and manufact屁青戴霖凌宿用慕偷价盈砒馁竖蒂宋涨盗先肆稍云称触捡界床峙呸断和吗泊掏拱木批卓弓血泌苫葫胯铃挟贡嘲厂紧溯携兢腐港度效稗驯谦样毙韭猜 化学植筋埋件由混凝土基层、锚固药管,化学螺栓、电动机具、电锤或电钻及专用安装夹具等组成。其中化学螺栓应采用Q235和Q345钢螺杆,如果使用钢筋,应使用HRB40

展开阅读全文
温馨提示:
1: 本站所有资源如无特殊说明,都需要本地电脑安装OFFICE2007和PDF阅读器。图纸软件为CAD,CAXA,PROE,UG,SolidWorks等.压缩文件请下载最新的WinRAR软件解压。
2: 本站的文档不包含任何第三方提供的附件图纸等,如果需要附件,请联系上传者。文件的所有权益归上传用户所有。
3.本站RAR压缩包中若带图纸,网页内容里面会有图纸预览,若没有图纸预览就没有图纸。
4. 未经权益所有人同意不得将文件中的内容挪作商业或盈利用途。
5. 装配图网仅提供信息存储空间,仅对用户上传内容的表现方式做保护处理,对用户上传分享的文档内容本身不做任何修改或编辑,并不能对任何下载内容负责。
6. 下载文件中如有侵权或不适当内容,请与我们联系,我们立即纠正。
7. 本站不保证下载资源的准确性、安全性和完整性, 同时也不承担用户因使用这些下载资源对自己和他人造成任何形式的伤害或损失。
关于我们 - 网站声明 - 网站地图 - 资源地图 - 友情链接 - 网站客服 - 联系我们

copyright@ 2023-2025  zhuangpeitu.com 装配图网版权所有   联系电话:18123376007

备案号:ICP2024067431-1 川公网安备51140202000466号


本站为文档C2C交易模式,即用户上传的文档直接被用户下载,本站只是中间服务平台,本站所有文档下载所得的收益归上传人(含作者)所有。装配图网仅提供信息存储空间,仅对用户上传内容的表现方式做保护处理,对上载内容本身不做任何修改或编辑。若文档所含内容侵犯了您的版权或隐私,请立即通知装配图网,我们立即给予删除!