GQZ球型支座设计全参数表

《GQZ球型支座设计全参数表》由会员分享，可在线阅读，更多相关《GQZ球型支座设计全参数表（45页珍藏版）》请在装配图网上搜索。

1、实用标准文案GQZI 列桥梁球型支座设计参数表设计承载力：100060000kN（执行标准 GB/T17955-2009）精彩文档名 称图号说明12GQZ-SX求型支座组装示意图3GQZ-SX求型支座主要设计参数表（表-1）411GQZ-D减型支座组装示意图12GQZ-D减型支座主要设计参数表（表-2）13 20GQZ-G球型支座组装示意图21GQZ-G球型支座主要设计参数表（表-3）22 25说 明一、本GQZ!（列桥梁球型支座设计参数表系与国标桥梁球型支座GB/T17955-2009配套产品，本参数表供生产厂家发布GQZ!（列产品信息使用，以方便桥梁设计人员选型。二、GQZ!（列支座的代号

2、举例：本例表示GQZ!（列桥梁球型支座承载力为10000kN,纵向位移士 100mm横向位移士 40mm转角为0.03rad的双向活动球形支座。三、GQZ!（列支座的主要技术性能1、支座竖向承载力分为 30 级，1000、1500、2000、2500、3000、3500、4000、4500、5000、6000、7000、8000、9000、10000、12500、15000、17500、20000、 22500、 25000、 27500、 30000、 32500、 35000、 37500、 40000、 45000、 50000、 55000、 60000kN。2、支座设计转角。分为 0

3、.02、0.03、0.04、0.05、0.06rad 五级。3、支座设计位移量：纵向位移：10004500kN, E1=50、E2 =100、E3 = 150mm500017500kN, Ei =100、巳=150、E = 200mm中交公路规划设计院有限公司名称说明图号12000037500kN4000060000kN,Ei =150、E2 = 200、E3 = 250mm ,Ei =200、E2 = 250、E3 = 300mm横向位移：SX （双向活动支座）,1000 9000kN, e=20mmi10000DX （单向活动支座）60000kN, e= 40mme= 3mm支座纵向、横向

4、位移量还可根据实际需要进行调整。4、支座可承受的水平力：单向活动支座（DX）及固定支座（GD在非滑移方向的水平力均不小于支座设计承载力的10%四、GQZ!（列支座安装：1、采用本系列支座时，安装支座的垫石混凝土强度等级不得低于C40级。100mm上，高度不小于 100mm且应布置钢筋。并按支座底2、安装支座处应设置支座垫石，垫石尺寸应按局部承压计算，其长度、宽度比支座底板尺寸大板地脚螺栓间距与底柱规格预留螺栓孔位置。若采用预埋钢板焊接连接时，支座就位后，用对称断续方式焊接，焊接过程中应防止支座钢体温度过高，防止变形、 烧坏聚四氟乙烯板等。3、支座安装标高应符合设计要求。控制垫石顶面标高时要注意

5、预留支座底板下专用砂浆垫层厚度。支座支承面四角高差不得大于1mm4、支座安装前方可开箱，并检查支座各部件及配件清单。支座安装前不允许随意拆卸固定件。5、支座安装的注意事项：1）支座安装位置划出中心十字，支座顺桥方向的中心线应与主梁顺桥向中心线平行。2）活动支座的上顶板与下底盆顺桥方向的中心线应重合。3）支座安装过程中，不得松开上顶板与下底盆的连接固定板，以防止发生过大的转角而倾覆。待支座安装完成后再拆除连接板，以防约束梁体的正常位移 与转动。4）检查不锈钢板外露面是否清洁，在运输、储存、安装过程中涂装是否碰掉，发现问题应及时清洁及补刷涂装，然后安装防尘设施。6、支座安装还应满足现行桥梁施工规范

6、的相关规定。支座使用期间，应按养护规范的有关规定定期进行检查及养护。中交公路规划设计院有限公司名称说明图号2法：1,主整件名称:1-下庆盆球蔽叫觥猫板s-球觥械1-期平面聚醵乙谕板5-平环锈钢板6-上顶板7-铜档属8-锚固索栓2、其主要尺寸见表-1。中交公路规划设计院有限公司名称GQZ-SX求型支座组装示意图图号3表-1 （一） GQZ系列桥梁球型支座（SX）双向活动支座主要尺寸（mm）序号规格、纵向位移量A9 =0.029 =0.039 =0.049 =0.059 =0.06EE2E3E1EE3E1E2E3E1E2日E1EE3EE2E31GQZ-1000士 50士 100士 15042052

7、0620440540640450550650一一一一一一2GQZ-1500士 50士 100士 150470570670480580680500600700一一一一一一3GQZ-2000士 50士 100士 150510610710540640740550650750一一一一一一4GQZ-2500士 50士 100士 150560660760580680780610710810一一一一一一5GQZ-3000士 50士 100士 150590690790620720820650750850一一一一一一6GQZ-3500士 50士 100士 1506307308306607608606907908

8、90一一一一一一7GQZ-4000士 50士 100士 150650750850680780880710810910一一一一一一8GQZ-4500士 50士 100士 150690790890720820920750850950一一一一一一9GQZ-5000士 100士 150士 200810910101084094010408709701070一一一一一一10GQZ-6000士 100士 150士 20089099010909201020112096010601160一一一一一一11GQZ-7000士 100士 150士 20093010301130970107011701010111012

9、10一一一一一一12GQZ-8000士 100士 150士 20096010601160101011101210106011601260一一一一一一13GQZ-9000士 100士 150士 200101011101210106011601260111012101310一一一一一一14GQZ-10000士 100士 150士 200105011501250109011901290114012401340一一一一一一15GQZ-12500士 100士 150士 200113012301339118012801380123013301430一一一一一一续表-1 （一） GQZ系列桥梁球型支座（SK

10、双向活动支座主要尺寸（mm）序号规格、纵向位移量A9 =0.029 =0.039 =0.049 =0.059 =0.06E1E2E3E1E2E3E1E2E3EE2EE1E2E3E1E2E316GQZ-15000+ 100+ 150+ 20012001300140012601360146013101410151013701470157014201520162017GQZ-17500+ 100+ 150+ 20012801380148013301430153013901490159014501550165015101610171018GQZ-20000+ 150+ 200+ 25014401540

11、164015001600170015601660176016301730183016901790189019GQZ-22500+ 150+ 200+ 25015401640174016001700180016701770187017301830193018001900200020GQZ-25000+ 150+ 200+ 25015501650175016501750185017201820192017901890199018601960206021GQZ-27500+ 150+ 200+ 25016501750185017101810191017801880198018501950205019

12、302030213022GQZ-30000+ 150+ 200+ 25017101810191017701870197018401940204019202020212019902090219023GQZ-32500+ 150+ 200+ 25017801880198018401940204019102010211019802080218020602160226024GQZ-35000+ 150+ 200+ 25018201920202018901990209019602060216020402140224021202220232025GQZ-37500+ 150+ 200+ 250187019

13、70207019402040214020102110221020902190229021802280238026GQZ-40000+ 200+ 250+ 30020402140224021002200230021802280238022702370247023502450255027GQZ-45000+ 200+ 250+ 30021202220232021802280238022602360246023502450255024402540264028GQZ-50000+ 200+ 250+ 300221023102410228023802480236024602560245025502650

14、25402640274029GQZ-55000+ 200+ 250+ 30022802380248023502450255024402540264025302630273026202720282030GQZ-60000+ 200+ 250+ 300236024602560243025302630252026202720262027202820272028202920表-1 （二） GQZ系列桥梁球型支座（SX）双向活动支座主要尺寸（mm）序号规格、横向 位移eBA9=0.029=0.039=0.049=0.059=0.069 =0.029 =0.039 =0.049 =0.059 =0.06E

15、E2E3E1E2E3EE2E3E1E2E3E1E2日1GQZ-1000士 20360380390一一360460560380480580390490590一一一一一一2GQZ-1500士 20410420440一一410510610420520620440540640一一一一一一3GQZ-2000士 20450480490一一450550650480580680490590690一一一一一一4GQZ-2500士 20500520550一一500600700520620720550650750一一一一一一5GQZ-3000士 20530560590一一5206207205506507505806

16、80780一一一一一一6GQZ-3500士 20570600630一一560660760590690790620720820一一一一一一7GQZ-4000士 20590620650一一580680780610710810640740840一一一一一一8GQZ-4500士 20630660690一一620720820650750850680780880一一一一一一9GQZ-5000士 20650680710一一720820920750850950780880980一一一一一一10GQZ-6000士 20730760800一一800900100083093010308709701070一一一一一一

17、11GQZ-7000士 20770810850一一8409401040880980108092010201120一一一一一一12GQZ-8000士 20800850900一一86096010609101010111096010601160一一一一一一13GQZ-9000士 20850900950一一9101010111096010601160101011101210一一一一一一14GQZ-10000409309701020一一9501050115099010901190104011401240一一一一一一15GQZ-1250040101010601110一一102011201220107011

18、701270112012201320一一一一一一续表-1 （二） GQZ系列桥梁球型支座（SK双向活动支座主要尺寸（mm）序号规格、横向 位移eBA19=0.029=0.039=0.049=0.059=0.069 =0.029 =0.039 =0.049 =0.059 =0.06E1E2E3E1E2EE1E2E3EE2E3E1E2E316GQZ-15000401080114011901250130010901190129011501250135012001300140012601360146013101410151017GQZ-175004011601210127013301390116012

19、60136012101310141012701370147013301430153013901490159018GQZ-20000+ 401220128013401410147013201420152013801480158014401540164015101610171015701670177019GQZ-22500+ 401320138014501510158014201520162014801580168015501650175016101710181016801780188020GQZ-25000+ 4013301430150015701640142015201620152016201

20、72015901690179016601760186017301830193021GQZ-27500+ 401430149015601630171015201620172015801680178016501750185017201820192018001900200022GQZ-30000+ 401490155016201700177015801680178016401740184017101810191017901890199018601960206023GQZ-32500+ 4015601620169017601840164017401840170018001900177018701970

21、18401940204019202020212024GQZ-35000+ 401600167017401820190016801780188017501850195018201920202019002000210019802080218025GQZ-37500+ 401650172017901870196017301830193018001900200018701970207019502050215020402140224026GQZ-40000+ 4017201780186019502030189019902090195020502150203021302230212022202320220

22、02300240027GQZ-45000+ 401800186019402030212019702070217020302130223021102210231022002300240022902390249028GQZ-50000+ 401890196020402130222020502150225021202220232022002300240022902390249023802480258029GQZ-55000+ 401960203021202210230021202220232021902290239022802380248023702470257024602560266030GQZ-

23、60000+ 4020402110220023002400219022902390226023602460235024502550245025502650255026502750表-1 （三） GQZ系列桥梁球型支座（SX）双向活动支座主要尺寸（mm）序BG DC、D号规格、999999999999999=0.02=0.03=0.04=0.05=0.06=0.02=0.03=0.04=0.05=0.06=0.02=0.03=0.04=0.05=0.061GQZ-1000300320330一一300320330一一240260270一一2GQZ-1500350360380一一350360380一

24、一290300320一一3GQZ-2000390420430一一390420430一一330360370一一4GQZ-2500440460490一一440460490一一380400430一一5GQZ-3000460490520一一470500530一一400430460一一6GQZ-3500500530560一一510540570一一440470500一一7GQZ-4000520550580一一530560590一一460490520一一8GQZ-4500560590620一一570600630一一500530560一一9GQZ-5000560590620一一590620650一一50053

25、0560一一10GQZ-6000640670710一一670700740一一580610650一一11GQZ-7000680720760一一710750790一一620660700一一12GQZ-8000700750800一一740790840一一640690740一一13GQZ-9000750800850一一790840890一一690740790一一14GQZ-10000830870920一一830870920一一730770820一一15GQZ-125009009501000一一9109601010一一800850900一一续表-1 （三） GQZ系列桥梁球型支座（SK双向活动支座主要尺

26、寸（mm）序 号7目 规格、B1G DC、D9=0.029=0.039=0.049=0.059=0.069=0.029=0.039=0.049=0.059=0.069=0.029=0.039=0.049=0.059=0.0616GQZ-15000970103010801140119098010401090115012008709309801040109017GQZ-17500104010901150121012701060111011701230129094099010501110117018GQZ-20000110011601220129013501120118012401310137010

27、00106011201190125019GQZ-2250012001260133013901460122012801350141014801100116012301290136020GQZ-2500012001300137014401510123013301400147015401100120012701340141021GQZ-2750013001360143015001580133013901460153016101240126013301400148022GQZ-300001360142014901570164013901450152016001670126013201390147015

28、4023GQZ-3250014201480155016201700146015201590166017401320138014501520160024GQZ-3500014601530160016801760150015701640172018001360143015001580166025GQZ-3750015101580165017301820155016201690177018601410148015501630172026GQZ-4000015701630171018001880162016801760185019301470153016101700178027GQZ-45000165

29、01710179018801970170017601840193020201550161016901780187028GQZ-5000017301800188019702060179018601940203021201630170017801870196029GQZ-5500018001870196020502140186019302020211022001700177018601950204030GQZ-60000187019402030213022301940201021002200230017701840193020302130表-1 （四） GQZ系列桥梁球型支座（SX）双向活动支座主

30、要尺寸（mm）序号xag规格H地脚螺栓底柱总重量（kg）e=0.02e=0.03e=0.04e =0.05e=0.069 =0.029 =0.039 =0.049 =0.059 =0.06EE2EE1巳E3E1E2E3E1巳E3E1巳E31GQZ-1000838485一一G 42X25255.661.867.962.569.075.466.673.279.9一一一一一一2GQZ-1500868788一一G 42X 25276.683.991.281.388.996.589.797.6105.4一一一一一一3GQZ-2000919293一一G 42X 25299.6108.0116.5114.1

31、123.1132.0119.5128.7137.9一一一一一一4GQZ-2500969799一一G 42X 252131.4141.1150.8142.8152.8162.9161.7172.4183.1一一一一一一5GQZ-3000100102103一一G 46X 260155.8166.6177.4175.7187.2198.6197.2209.1221.3一一一一一一6GQZ-3500105106108一一G 46X 260190.9202.9215.0212.1224.7237.4236.2249.5262.8一一一一一一7GQZ-4000109111113一一G 46X 260214

32、.0226.8239.7238.7252.3266.0264.8279.1293.4一一一一一一8GQZ-4500113115117一一G 46X 260254.6269.0283.4282.2397.1312.2311.3327.0342.6一一一一一一9GQZ-5000117119121一一G 58X 300298.2313.5328.5328.1344.1360.1359.8376.5393.1一一一一一一10GQZ-6000125127130一一G 58X 300405.2423.4441.7442.9462.0481.0494.0514.0534.0一一一一一一11GQZ-70001

33、32134137一一G 58X 300480.3500.7521.2535.3556.9578.3592.8615.4638.0一一一一一一12GQZ-8000139141143一一G 70X 352549.0572.2595.4623.5648.1672.7701.6727.6753.6一一一一一一13GQZ-9000145147149一一G 70X 352651.2677.1703.0734.7762.1789.5821.3850.3879.3一一一一一一14GQZ-10000152154156一一G 70X 352767.4797.2827.0839.3870.5901.4933.896

34、6.5999.2一一一一一一15GQZ-12500173175177一一G 80X 3521038.41074.01109.61148.61186.01223.41270.81309.91349.0一一一一一一续表-1 （四） GQZ系列桥梁球型支座（SR双向活动支座主要尺寸（mm）序号规格H地脚螺栓底柱总重量（kg）e =0.02e =0.03e =0.04e =0.05e =0.069 =0.029 =0.039 =0.049 =0.059 =0.06E1巳E3E1巳E3E1E2E3E1巳E3E1E2E316GQZ-15000188192196200(201)204( 205)G 80X

35、3521303.81343.71383.51457.91499.91541.81588.81632.51676.31803.81831.91891.41946.61994.42056.817GQZ-17500199201205(206)209(210)214(215)G 90X 4001581.71626.21670.81726.51772.91819.41903.21952.01951.32128.12179.22245.52347.02415.92470.418GQZ-20000214216221224229G 90X 4001942.41993.12043.82145.52198.522

36、51.82384.82440.52496.22643.82702.32760.82895.62956.73017.719GQZ-22500221223227232238G 90X 4002371.02427.92484.82593.52652.92712.32880.02942.43004.73149.43214.53279.13480.43548.53616.620GQZ-25000232236241247250100X2553.42612.82672.22920.43014.23078.13270.03336.93403.83619.03689.13759.13947.24020.2409

37、3.421GQZ-27500243245251254261100X3084.23150.33216.53339.13407.93476.83702.03774.23846.34043.14118.64193.94493.14572.14650.622GQZ-30000255258262268273100X3516.73587.93659.13809.03882.13956.24175.24252.64329.94633.94715.24796.55049.95134.55219.223GQZ-32500267270274281286110X4603936.54011.34086.14241.5

38、4328.64416.24648.64730.04811.35122.15207.55293.05604.15693.15782.124GQZ-35000277279286291296110X4604369.74451.74533.64729.14814.24899.35199.35288.35377.15688.05780.55873.16238.16334.86431.525GQZ-37500286289293302307110X4897.84988.35078.95315.05409.45503.85774.05872.35970.66350.86453.46556.07038.3714

39、5.97253.526GQZ-40000297300304310315120X5629.55727.95826.36022.46124.36226.16488.76595.16701.57272.17383.67495.27899.88016.08132.127GQZ-45000323324329334344120X6709.86819.86929.77125.37239.17352.77781.67900.28018.98535.78659.98784.09417.79547.39677.028GQZ-50000342344346354363480G124X7833.07953.08073.

40、08385.98510.48635.09057.39186.99316.49951.610086.10223.10905.11046.11187.29GQZ-55000361363366373381520M24X8846.98976.09105.19509.39643.19776.810354.10493.10633.11809.811955.1 12101.0 12334.012486.1 12637.30GQZ-60000379381385393400520 128X56010132.610273.410414.10806.210951.811097.30 11759. 611910.93

41、 12067.318 12931.94 13090.1 13247.4614130.32 14295.9714461.1中交公路规划设计院有限公司名称GQZ-SX型支座E要尺寸表图号11 I注：1 .主翻件钠：1-、蛭2_林聚醵乙猫板3-球面蒯板4-醐平面聚四萦端板5-平而不僦板6-上可机/-罐国8-锚固黏9-聚四家区向滑条1不锈蒯响解2其主款寸见表- 2.中交公路规划设计院有限公司名称GQZ-DX求型支座组装示意图图号12表-2 （一）GQZ系列桥梁球型支座（DK单向活动支座主要尺寸（mm）序号规格、纵向位移量A9 =0.029 =0.039 =0.049 =0.059 =0.06E1E2E

42、3EE2E3E1E2E3E1E2E3EE2E3E1E2E31GQZ-1000+ 50+ 100+ 150420520620440540640450550650一一一一一一2GQZ-1500+ 50+ 100+ 150470570670480580680500600700一一一一一一3GQZ-2000+ 50+ 100+ 150510610710540640740550650750一一一一一一4GQZ-2500+ 50+ 100+ 150560660760580680780610710810一一一一一一5GQZ-3000+ 50+ 100+ 150590690790620720820650750

43、850一一一一一一6GQZ-3500+ 50+ 100+ 150630730830660760860690790890一一一一一一7GQZ-4000+ 50+ 100+ 150650750850680780880710810910一一一一一一8GQZ-4500+ 50+ 100+ 150690790890720820920750850950一一一一一一9GQZ-5000+ 100+ 150+ 200810910101084094010408709701070一一一一一一10GQZ-6000+ 100+ 150+ 20089099010909201020112096010601160一一一一一一

44、11GQZ-7000+ 100+ 150+ 2009301030113097010701170101011101210一一一一一一12GQZ-8000+ 100+ 150+ 20096010601160101011101210106011601260一一一一一一13GQZ-9000+ 100+ 150+ 200101011101210106011601260111012101310一一一一一一14GQZ-10000+ 100+ 150+ 200105011501250109011901290114012401340一一一一一一15GQZ-12500+ 100+ 150+ 200113012301339118012801380123013301430一一一一一一续表-2 （一） GQZ系列桥梁球型支座（DK单向活动支座主要尺寸（mm）序 号规格纵向位移量A9 =0.029 =0.039 =0.0