X3底盘组结构图册(new)

《X3底盘组结构图册(new)》由会员分享，可在线阅读，更多相关《X3底盘组结构图册(new)（49页珍藏版）》请在装配图网上搜索。

1、 比亚迪F8轿车结构图册一、底 盘 组 C H A S S I S图1-1序号No.零件编号Part No.名 称Description数量Qty备注Rem中文Chinese英文English1BYDX3-1109010进气管前段总成Inlet pipe, front 12Q1400616六角头螺栓和平垫圈组合件Ass hex-bolt13BYDX3-1109021前部盲管Front duct14BYDX3-1109022前部盲管固定卡扣Clip,front duct15BYDX3-1109023橡胶衬套1Rubber bush 146BYDX3-1109030谐振腔Resonator ,in

2、take air 17BYDX3-1109040进气管后段总成Inlet pipe,rear 18BYDX3-1109100空气滤清器箱体总成House, air filter19BYDX3-1109201空气滤清器滤芯Filter core110BYDX3-1109202空气滤清器滤芯安装支架Frame,air filter111BYDX3-1109911空气滤清器滤芯固定螺钉Bolt,air filter212BYDX3-1109024橡胶衬套2Rubber bush 2113Q67676B型蜗杆传动式软管环箍Clamp 114BYDX3-1109061进气弯管Hose air inlet

3、115BYDX3-1109062弯管接头Tie-in,hose air inlet1图1-1图1-1图1-1序号No.零件编号Part No.名 称Description数量Qty备注Rem中文Chinese英文English16BYDX3-1109071曲轴箱强制通风管Vent-pipe ,crankcase117Q67689B型蜗杆传动式软管环箍Clamp 1图1-2序号No.零件编号Part No.名 称Description数量Qty备注Rem中文Chinese英文English1Q32010六角法兰面螺母Nut,.flange42BYDX3-1203015焊接螺栓Bolt43BYDX

4、3-1200051前段排气管接口密封垫Sealing ring14BYDX3-1203010前段排气管总成Front exhaust pipe15BYDF3-1203201球面密封圈Sealing cushion16BYDF3-1203312弹簧（长43）Spring(Length 43)27BYDF3-1203311连接螺栓（杆长39）Linking Bolt(Available Length 39)28BYDF3-1200110橡胶吊挂Rubber support49Q1840816六角法兰面螺栓Bolt,flange410BYDX3-1200040中段排气管橡胶吊挂固定支架Bracket

5、 ,rubber support111BYDX3-1203020中段排气管焊接总成Middle exhaust pipe112BYDX3-1200010中段排气管橡胶吊挂固定支架Bracket ,rubber support113BYDX3-1200911六角法兰面螺栓和平垫组合件Ass hex-bolt,flange114Q1461045六角头螺栓、弹簧垫圈和平垫圈组合件Ass hex-bolt14图1-2图1-2图1-2序号No.零件编号Part No.名 称Description数量Qty备注Rem中文Chinese英文English15BYDX3-1200031密封垫Sealing c

6、ushion116BYDF3-1208104组合螺母M6Assembled nut M6717BYDX3-1208011隔热板Heat isolation board118BYDX3-1203030后段排气管焊接总成Rear Exhaust Pipe119BYDF3-1200320橡胶吊挂Rubber support120BYDX3-1200912六角法兰面螺栓和平垫组合件Ass hex-bolt,flange121Q1410516L六角头螺栓和锥形弹性垫圈组合件Ass hex-bolt322BYDX3-1208013隔热板Heat isolation board1图1-3图1-3序号No.零

7、件编号Part No.名 称Description .数量Qty备注Rem中文Chinese英文English1BYDX3D-1001040变速箱前悬置总成Front mounting12BYDF3D-1001130变速箱前悬置支架BRK, Front mounting13Q1841225六角法兰面螺栓Hex-bolt W/T flange54BYDEG1001911六角法兰面螺栓Hex-bolt W/T flange35Q1861025六角法兰面螺栓（加大）Bolt,.flange26BYDX3D1001100发动机右悬置弹性铰接及安装支座总成Right mounting17BYDF3D-1

8、001520橡胶套Rubber bush18BYDX31001201发动机右悬置安装支架BRK, Right mounting19Q1841025六角法兰面螺栓Hex-bolt W/T flange410BYDX31001911六角头螺栓与大垫圈组合件Ass, bolt，washer311Q32012六角法兰面螺母Nut,.flange612BYDX3D1001030变速箱后悬置总成Rear mounting113Q14610100六角头螺栓、弹簧垫圈和平垫圈组合件Ass,blot,spring washer,washer2图1-3图1-3序号No.零件编号Part No.名 称Descrip

9、tion .数量Qty备注Rem中文Chinese英文English14Q33810非金属嵌件六角法兰面锁紧螺母Hex-nut W/T flange215Q1461025六角头螺栓、弹簧垫圈和平垫圈组合件Ass,blot,spring washer,washer116BYDX3D1001061变速箱后悬置支架BRK, Rear mounting117BYDX3D1001020变速箱左悬置总成Left mounting118BYDX3D1001051变速箱左悬置支架BRK, Left mounting119Q32010六角法兰面螺母Nut,.flange1图1-4图1-4序号No.零件编号Par

10、t No.名 称Description数量Qty备注Rem中文Chinese英文English1BYDX3-1101400燃油箱总成Fuel tank comp12BYDX3-1104051五孔管夹Stay clamp,fuel pipe103BYDX3-1106010燃油泵总成Fuel pump comp14BYDF3-1101201油泵O型密封圈Gasket fuel suction tube set15BYDF3-1101202油泵弹性挡圈Plate,fuel tank vent tube set16BYDF3-1101500防侧倾阀总成List valve17BYDF3-1101501

11、防侧倾阀密封垫List valve，pad18BYDF3-1101502防侧倾阀盖板List valve,cover board19Q2360512十字槽盘头螺钉Cross headed scew410BYDX3-1101404防撞垫Cushion,fuel tank311Q673B105钢带型弹性环箍Snap ring 2#212BYDX3-1101800加油口盖总成Gasket,fuel tank cap113Q2734819十字槽大半圆头自攻螺钉Cross headed scew314BYDX3-1101700加油管防尘罩总成Shield assy,fuel tank filler pi

12、pe115Q671B112钢丝型弹性环箍Snap ring116BYDX3-1101701防尘罩溢油管Shield assy,out fuel pipe1图1-4序号No.零件编号Part No.名 称Description数量Qty备注Rem中文Chinese英文English17BYDX3-1101100加油管上段总成Top inlet pipe assy118Q1840830六角法兰面螺栓Bolt319Q673B18钢带型弹性环箍Snap ring420Q67550蜗杆卡箍Worm snap ring 1#421BYDX3-1101202加油软管Hose-joint 2#122BYDX3

13、-1101201加油软管Hose-joint 1#123BYDX3-1101311下段加油管Next inlet pipe 124BYDX3-1101203加油软管Hose-joint 3#125BYDX3-1101204加油软管Hose-joint 4#126BYDX3-1101500油箱固定带总成Band sub-assy,fuel tank 1#127BYDX3-1101600油箱固定带总成Band sub-assy,fuel tank 2#128Q1400830六角组合螺栓Blot429BYDX3-1208012油箱隔热垫Protector,fuel tank130Q1460620六角

14、头螺栓、弹簧垫圈和平垫圈组合件Ass,blot, spring washer, washer331Q1460612六角头螺栓弹簧垫圈和平垫圈组合件Ass,blot, spring washer, washer332BYDX3-1101121安装支架Install bracket 1#图1-4图1-4图1-4序号No.零件编号Part No.名 称Description数量Qty备注Rem中文Chinese英文English33BYDX3-1101131安装支架Install bracket 2#134BYDX3-1101331安装支架Install bracket 3#135BYDX3-110

15、1341安装支架Install bracket 4#136BYDX3-1101351安装支架Install bracket 5#137BYDX3-1101361安装支架Install bracket 6#138BYDX3-1101321下段通气管Next tube,for breather 1图1-5图1-5序号No.零件编号Part No.名 称Description数量Qty备注Rem中文Chinese英文English39BYDX3-1130031燃油蒸发软管Hose,fuel evaporation 3#140Q673B12钢带型弹性环箍Snap ring 1#441BYDX3-110

16、4031供油硬管Fuel pipe142BYDX3-1130051燃油蒸发硬管Sludge drainage pipe143BYDX3-1104041高压供油橡胶软管Inlet hose-engine144Q67522蜗杆卡箍Worm snap ring 2#245BYDX3-1130041燃油蒸发软管Hose,fuel evaporation 1#146BYDX3-1130010碳罐总成Charcoal canister comp.147BYDX3-1130070炭罐安装支架总成Bracket,charcoal canister comp.148Q32006六角法兰面螺母Nut249BYDX

17、3-1130021通气软管Hose-breather150BYDX3-1130061燃油蒸发软管Hose,fuel evaporation 2#151Q1840510六角法兰面螺栓Nut152Q32005六角法兰面螺母Blot2图1-5图1-5序号No.零件编号Part No.名 称Description数量Qty备注Rem中文Chinese英文English53BYDX3-1104020供油快接管Supply fuel joint pipe 2#154BYDX3-1104010供油快接管Supply fuel joint pipe 1#155BYDX3-1117010燃油滤清器总成Fuel

18、filter comp156BYDX3-1117020滤清器安装支架总成Fuel filter bracket comp157Q1460516六角头螺栓、弹簧垫圈和平垫圈组合件Ass,blot, spring washer, washer158BYDX3-1104052单孔管夹Stay clamp,fuel pipe1图1-6序号No.零件编号Part No.名 称Description数量Qty备注Rem中文Chinese英文English1Q1400816螺栓Blot22BYDX3-1302012散热器右支架Radiator bracket, R13BYDX3-1302011散热器左支架R

19、adiator bracket, L14BYDF3-1302102上悬置橡胶衬套Rubber cushion25BYDX3-1301010散热器总成Radiator16BYDX3-1302021下悬置橡胶衬套Rubber cushion27Q1840616六角法兰面螺栓Blot, flange88BYDX3-1302031冷却液供给管支架Hose bracket19Q67638蜗杆式环箍Worm snap ring410BYDX3D-1303011散热器进水管Radiator inlet hose111BYDX3D-1303021散热器出水管Radiator outlet hose112Q67

20、3B11钢带型弹性环箍Clamp313BYDX3-1303031冷却液供给管Hose, expand tank114BYDX3-1311010冷却液壶总成Expand tank assy115BYDX3-1311021冷却液壶通气管Aerate hose116Q32006六角法兰面螺母Nut, flange117BYDX3-1308010风扇总成Fan118Q310B06方螺母Nut8与7配合19BYDX3-1304010散热器盖Radiator cover1图1-6图1-6图1-6序号No.零件编号Part No.名 称Description数量Qty备注Rem中文Chinese英文Engl

21、ish20BYDX3-1305012密封圈ring121BYDX3-1305011放水开关Water drain tap1图1-7图1-7序号No.零件编号Part No.名 称Description数量Qty备注Rem中文Chinese英文English1BYDX3-1602011离合踏板垫Pad，clutch pedal12BYDX3-1602012离合踏板臂Arm，clutch pedal13Q2150860内六角花形盘头螺钉Bolt M086014BYDX3-1602013离合踏板托架Bracket，clutch pedal15Q32008螺母M8Nut M816BYDX3-16020

22、21离合踏板小支架Bracket，clutch pedal17Q32008螺母M8Nut M838BYDX3-1602014弹簧上支承座abutment19BYDX3-1602015离合踏板助力弹簧Spring，clutch pedal110BYDX3-1602016弹簧下支承座abutment111BYDX3-1608010离合总泵Master cylinder，clutch112Q40010小垫圈gasket113BYDX3-1607011离合油管Clutch hose114Q673B14钢带型弹性环箍Clip -hose215Q32008螺母M8Nut M8216Q40310弹簧垫10S

23、pring washer 10217BYDX3-1607021油管接头螺母Nut, hose118BYDX3D-1607020离合油管Clutch control hose119Q50110锁销lockpin120BYDF3-3506133E型卡E-clip1图1-8图1-8序号No.零件编号Part No.名 称Description数量Qty备注Rem中文Chinese英文English1BYDX3-5516010操纵手柄头总成Shift handle assy12BYDX3-1703011操纵手柄Shift handle13BYDX3-1703012上壳体Upper box14BYDX3

24、-1703013下壳体Lower box15BYDX3-1703014轴销Shaft pin16BYDX3-1703015选档支架Shift bracket17BYDX3-1703016选档支架压簧Spring ,shift control lever18BYDX3-1703017橡胶防尘罩Rubber dust boot19Q2723513十字槽盘头自功螺钉Cross head screw310BYDX3-1703018金属压板Protective plate111Q1840830六角法兰面螺栓Hex-bolt W/T flange412Q2620620十字槽盘头自功锁紧螺钉Cross he

25、ad screw413BYDX3-1703020换位拉索总成Select cable114BYDX3-1703030换档拉索总成Shift cable115BYDX3-1703045E型卡片E-shaped clamp216BYD624-1703106弹簧卡片Spring clamp217Q50108锁销Split pin2图1-8图1-8 序号No.零件编号Part No.名 称Description数量Qty备注Rem中文Chinese英文English18BYD624-1703102固定卡簧Fixation spring clamp219BYDX3-5516022压圈Fixed ring

26、120BYDX3-5516021防尘罩Dust boot1图1-9序号No.序号No.零件编号Part No.名 称Description数量Qty备注Rem中文Chinese英文English1BYDX3D-2203010-C左传动轴总成Shaft assy,front drive,LH12BYDX3D-2208010-C连接轴轴总成Connecting Shaft assy13BYDX3D-2203020-C右传动轴总成Shaft assy,front drive,RH14Q5005032开口销split pin25BYDF3-2203011传动轴螺母Nut of propeller sh

27、aft26RF95176.0FJ-5垫圈Washer27AC9204.0球笼式万向节FF Universal joint28L9586.0-2轮侧防尘罩组件Dust boot kit,whee side29L9586.0-2差速器侧防尘罩组件Dust boot kit, differencial side210GI9211.0F3三球销万向节GI Universal joint111R9218.0-3轴承支座Bearing abutment112Q1841040外六角法兰面螺栓Flange bolt113BYDX3-2203911中间支承固定螺栓Fixing bolt214GI9213.0三球

28、销万向节GI Universal joint1图1-10序号No.零件编号Part No.名 称Description数量Qty备注Rem中文Chinese英文English1BYDX3-3402010转向盘总成Steering wheel assy12Q1841030六角法兰面螺栓Flange bolt13BYDX3-3404010转向轴及万向节总成Columniation and gimbal assy14Q32008六角法兰面螺母Hex-bolt W/T flange25Q1500820六角头螺栓Hex-bolt26Q1460830六角头螺栓、弹簧垫圈和平垫圈组合件Hex-bolt an

29、d spring washer assy17BYDX3-3412012转向防尘罩Steering duct boot18BYDX3-3412013钢套Steel bush39Q1840620六角法兰面螺栓Flange bolt3图1-10图1-11图1-11序号No.零件编号Part No.名 称Description数量Qty备注Rem中文Chinese英文English1BYDX3-3404001扭簧Spring12BYDX3-3404002六角锁紧螺母Flange hex-bolt13BYDX3-3404003推动滚针轴承Roller bearing14BYDX3-3404004轴承支架

30、Bearing bracket15BYDX3-3404005垫圈Washer16BYDX3-3404006滑动锁块Slip locked-block17BYDX3-3404007锁紧弹簧Retaining spring18BYDX3-3404008固定锁块Locked block19BYDX3-3404009滑动垫片Slip washer110BYDX3-3404010管柱总成Steering column assy111BYDX3-3404011轴承Bearing112BYDX3-3404012大垫圈Large washer113BYDX3-3404013锁紧凸轮Locked cam114B

31、YDX3-3404014手柄Shift handle115BYDX3-3404015连接螺栓Linking bolt116BYDX3-3404016转向轴Steering column shaft117BYDX3-3404017限位卡簧Fixation spring clamp1图1-11序号No.零件编号Part No.名 称Description数量Qty备注Rem中文Chinese英文English18BYDX3-3404018锁销Lock pin119BYDX3-3404019安装支架Mounting bracket120BYDX3-3404020支撑套Supporting set12

32、1BYDX3-3404021支架Bracket122BYDX3-3404022下传动轴Steering shaft assy, lower123BYDX3-3404023花键套Spline cover124BYDX3-3404024套筒Sleeve125BYDX3-3404025套筒节叉Sleeve joint126BYDX3-3404026挡块Block127BYDX3-3404027十字轴总成Gimbal assy128BYDX3-3404028节叉Joint1图1-11图1-12序号No.零件编号Part No.名 称Description数量Qty备注Rem中文Chinese英文Eng

33、lish1BYDX3-3411100外球节总成（左）Outside ball head assy L12BYDF3-3401011拉杆锁紧螺母Locking nut ,tie rod23BYDF3-3401012卡箍Snap ring24BYDX3-3401030齿条防护罩Rack dust boot25BYDF3-3401031单耳无级卡箍Snap ring26BYDF3-3401040内球节总成Inside ball head assy27BYDF3-3401051齿条锁片Rack locking-clamp28BYDF3-3401052大锥接头Wimble-shaped tie-in(B

34、)29BYDF3-3401053上油封Upper oil seal110BYDF3-3401054上轴承Upper bearing111BYDX3-3411011阀芯总成Valve core112BYDF3-3401056中轴承Mid bearing113BYDF3-3401057下油封Lower oil seal114BYDF3-3401058小锥接头Wimble-shaped tie-in(S)215BYDF3-3401059油嘴锥接头Oil nib tie-in216BYDF3-3401060减震套总成Damping sleeve assy217BYDF3-3401071右支架锁紧螺栓B

35、locking bolt ,bracket R118BYDF3-3401072弹簧垫圈Spring washer1图1-12图1-12图1-12序号No.零件编号Part No.名 称Description数量Qty备注Rem中文Chinese英文English19BYDF3-3401070右支架总成Bracket assy R120BYDF3-3401073六角头螺栓和平垫圈组合件Hex-bolt with washer assy121BYDF3-3401074右支架衬套Bracket bush R122BYDX3-3401081右油管总成Oil pipe assy R123BYDX3-34

36、01082左油管总成Oil pipe assy L124BYDF3-3401090壳体油缸总成Gear box assy125BYDF3-3401091齿条支乘座垫Cushion ,rack bracket126BYDF3-3401092齿条支乘座Rack bracket127BYDF3-3401093弹簧spring128BYDF3-3401094调整螺塞Adjust bolt129BYDF3-3401095锁紧螺母Blocking nut130BYDF3-3401096下轴承Lower bearing131BYDF3-3401097六角法兰螺母Hex-nut W/T flange132BY

37、DF3-3401098堵盖Lid133BYDF3-3401099垫片washer234BYDF3-3401201齿条高压油封Oil seal ,rack235BYDF3-34012020型橡胶密封圈O-shaped rubber washer1图1-12图1-12序号No.零件编号Part No.名 称Description数量Qty备注Rem中文Chinese英文English36BYDF3-3401203活塞环Piston ring137BYDF3-3401210齿条总成Rack assy138BYDF3-3401211衬套sleeve139BYDF3-34012120型橡胶密封圈O-sh

38、aped seal washer140BYDF3-3401213限位套Limit sleeve141BYDX3-3411200外球节总成（右）Ball head assy R1图1-13序号No.零件编号Part No.名 称Description数量Qty备注Rem中文Chinese英文English1BYDF3-3407000转向油泵总成Oil pump , redirector12BYDX3B-3412051油泵安装支架IIOil pump bracket II13Q1421025组合螺栓Ass bolt44Q32010六角法兰面螺母Hex-bolt W/T flange15BYDX3B

39、-3412062调整滑块Adjust block16BYDX3B-3412061油泵调节支架Adjust bracket ,oil pump17Q18408100六角法兰面螺栓Flange bolt18Q18410125六角法兰面螺栓Flange bolt19BYDX3B-3412041油泵安装支架ISpring snap ring110BYDX3-3406031进油软管Hose ,oil inlet111Q67522弹性卡箍Spring snap ring212BYDX3-3412030双管固定夹板III总成Double clamping plate III assy113Q1460616六

40、角头螺栓、弹簧垫圈和平垫圈组合件Hex-bolt and spring washer assy514BYDX3-3412015橡胶衬套Rubber bush515BYDX3-3412017橡胶衬套Rubber bush116BYDX3-3412016双管固定夹板IVDouble clamping plate IV1图1-13图1-13图1-13序号No.零件编号Part No.名 称Description数量Qty备注Rem中文Chinese英文English17Q1420830组合螺栓Ass hex-bolt218BYDF3-3406101空心螺栓Hollow bolt119BYDF3-34

41、06102紫铜垫圈Purple cuprum washer220BYDX3-3406010转向高压油管总成Inlet oil pipe assy121BYDF3B-3406112进油管管夹IClamp I，Inlet oil pipe122BYDF3B-3406113进油管管夹IIClamp II，Inlet oil pipe123BYDX3-3406020回油管总成Pipe assy, oil return124BYDX3-3412073橡胶衬套Rubber bush225BYDX3-3412014双管固定夹板IIDouble clamping plate II126BYDX3-341202

42、0双管固定夹板I总成Double clamping plate I assy127BYDX3-3412018双管固定夹Double stay clamp128Q67527弹性卡箍Snap ring229BYDX3-3406032回油软管Hose ,oil return130BYDF3-3408100动力转向油罐总成Oil reservoir assy , drive redirector131Q1840816六角法兰面螺栓Hex-bolt W/T flange2图1-14序号No.零件编号Part No.名 称Description数量Qty备注Rem中文Chinese英文English1BY

43、DX32810020水箱下横梁总成Beam assy,.under water tank12BYDX32810072水箱下横梁右连接板Right connecting board13Q1460816六角头组合螺栓Ass bolt,.flange84BYDX32810061右前吊架支撑板Supporting board,.R.F15Q1861240六角法兰面螺栓Bolt flange26BYDX32810051左前吊架支撑板Supporting board,.L.F17BYDX32810071水箱下横梁左连接板Left connecting board18Q32008六角法兰面螺母Nut,.fl

44、ange29BYDX3D-2810090中纵梁焊接组件Mid-beam welding components110BYDX3D-2810912中纵梁总成连接螺栓Mid-beam connecting bolt assembly211BYDX3D-2810383大垫圈Large washer212BYDX3D-2810382中纵梁橡胶衬套Mid-beam rubber bush213BYDX3D-2810381中纵梁橡胶减振块Mid-beam rubber buffer2图1-15图1-15序号No.零件编号Part No.名 称Description数量Qty备注Rem中文Chinese英文E

45、nglish1BYDX3-2810010前副车架主体焊接总成Front assist frame assy.12BYDX32904911六角法兰面螺栓和平垫圈组合件Comp Bolt flanging 23BYDX3-2810030副车架左吊架总成Right connecting board Assem14BYDX3-2810040副车架右吊架总成Left connecting board Assem15BYDX3-2904010左摆臂总成Left Rocker arm assy16BYDX3-2904020右摆臂总成Right Rocker arm assy17Q32212L六角螺母和锥形弹性垫圈组合件Comp blot,.fla