点击查看架空裸绞线 内容-架空导线

《点击查看架空裸绞线 内容-架空导线》由会员分享，可在线阅读，更多相关《点击查看架空裸绞线 内容-架空导线（19页珍藏版）》请在装配图网上搜索。

1、架 空 导 线Overhead Conductors目 录 Content铝绞线和钢芯铝绞线 AAC & ACSR铝合金绞线和钢芯铝合金绞线 AAAC & AAACSR铝包钢芯铝绞线 Al-clad Steel Core Al Stranded Wire裸电线的产品维护Maintenance of Bare Conductors顾客订货须知 Ordering Information for Customers产品新老型号对照表 Comparison Table of new and old types铝绞线和钢芯铝绞线Aluminum Stranded Conductor (AAC) &Alu

2、minum Conductor Steel Reinforced (ACSR)一、用途 Application铝绞线和钢芯铝绞线具有构造简朴、架设和维护以便、线路造价低、传播容量大、又利于跨越江河和山沟等特殊地理条件的敷设等特点，因此该产品广泛应用于多种电压级别的输配电线路中。AAC and ACSR have been widely used in power transmission lines with various voltage levels, since they have such good characteristics as simple structure, conven

3、ient installation and maintenance, low cost for the line, large transmission capacity and are also suitable for laying across rivers and valleys where special geographical features exist.二、型号 Type1、铝绞线的型号Type of the aluminum stranded conductor (AAC) : JL2、一般型钢芯铝绞线的型号Type of the common ACSR：JL/G1A、JL

4、/G1B 3、高强度钢芯铝绞线的型号Type of the high-strengthened ACSR：JL/G2A、JL/G2B4、特高强度级钢芯铝绞线的型号Type of the super-high-strengthened ACSR: JL/G3A5、防腐型钢芯铝绞线的型号Type of the anti-corrosion ACSR： JL/G1AF、JL/G2AF、JL/G3AF三、规格 Specification1、 铝绞线和钢芯铝绞线的规格用相称于硬圆铝线的导电截面积的规格表达。面积单位为mm2。Specifications of AAC and ACSR are denot

5、ed with conductive cross-section of hard round aluminum wire in mm2.2、铝绞线的规格和产品构造见表1。Specification and structure of AAC see Table 1.3、钢芯铝绞线的规格和产品构造见表2。Specification and structure of ACSR see Table 2.四、产品性能 Product Performance1、 铝绞线和钢芯铝绞线的电性能以其20时的千米直流电阻表达。绞线所用硬铝线的电阻率不不小于国际通用原则值28.264 nm。The electric

6、al performance of AAC and ACSR is indicated in DC /km(20). The resistivity of the hard aluminum wire for stranded wires is not greater than 28.264 nm of international standard value.2、 铝绞线的额定抗拉力以构成铝绞线的所有铝线的截面积总和与铝线原则规定的相应规格最小抗拉强度的乘积表达。The rated tensile strength of AAC is denoted with the result of t

7、otal cross-section of all aluminum conductors multiplied by min. tensile strength of corresponding size specified in the standard for aluminum wire.3、 钢芯铝绞线的额定抗拉力以构成钢芯铝绞线的铝部抗拉力与钢部抗拉力之和表达。The rated tensile strength of ACSR is denoted with the sum of all aluminum conductors tensile strength and steels

8、 tensile strength.a 铝部抗拉力以铝线截面积总和与铝线原则规定的相应规格的最小抗拉强度的乘积表达。The tensile strength of all aluminum conductors is denoted with the result of all cross-sections of aluminum conductors multiplied by min. tensile strength of corresponding size specified in the standard for aluminum wire.b钢部抗拉力以钢线截面积总和与钢线原则规

9、定的相应规格的伸长1时应力的乘积表达。The tensile strength of all steel wires is denoted with the result of all cross-sections of steel wires multiplied by stress at 1% elongation of corresponding size specified in the standard for steel wire.铝绞线和钢芯铝绞线的产品性能见表1、2。Performance of AAC and ACSR see Table 1、2.五、材料原则 Materia

10、l Standard1、 铝绞线和钢芯铝绞线用硬铝线执行GB/T 17048-1997原则（等效采用IEC 60889：1987原则）。The hard aluminum conductor used for AAC and ACSR implements the standard GB/T 17048-1997 ( equivalent to IEC 60889: 1987).2、 钢线用镀锌钢丝执行IEC 60888：1987原则。The zinc coated steel wire used for ACSR implements IEC 60888: 1987.3、根据顾客需要，可按顾

11、客提出的材料原则和规定组织生产。Production can be organized according to customers requirements for material standard, etc.表1 JL铝绞线规格、构造和性能Table 1. Specification, structure and properties of AAC (JL)规格Specification面积Areamm2单线根数No. of single wiresn直径Diameter单位长度重量Weightkg/km额定抗拉力rated tensile strengthkN直流电阻20DC resi

12、stanceat 20/km单线single绞线strandsmmmm10162540631016254063777771.351.712.132.703.394.055.126.408.0910.227.443.868.4109.4172.31.953.044.506.8010.392.86331.78961.14530.71580.454510012516020025010012516020025019191919192.592.893.273.664.0912.914.516.418.320.5274.8343.6439.8549.7687.117.0021.2526.4032.0040

13、.000.28770.23020.17980.14390.115131540045050056031540045050056037373737373.293.713.944.154.3923.026.027.529.030.7867.91102.01239.81377.61542.951.9764.0072.0080.0089.600.09160.07210.06410.05770.05156307108009001000630710800900100061616161613.633.854.094.334.5732.634.636.839.041.11738.31959.12207.4248

14、3.32759.2100.80113.60128.00144.00160.000.04580.04070.03610.03210.028911201250140015001120125014001500919191913.964.184.434.5843.546.048.750.43093.53452.63866.94143.1179.20200.00224.00240.000.02580.02310.02070.0193表2 JL/G1A、JL/G1B、JL/G2A、JLG2B、JL/G3A钢芯铝绞线规格、构造和性能Table 2. Specifications, structures an

15、d properties of ACSR (JL/G1A、JL/G1B、JL/G2A、JLG2B、JL/G3A)规格Spec钢比St.面积Area单线根数No. of wires单线直径Diameter of wire直径Diameter单位长度重量Weightkg/km额定抗拉力Rated tensile strength直流电阻20DCresistanceat 20/km铝Al钢St总和Sum铝Al钢St铝Al钢St钢芯St core绞线StrandsJL/G1AJL/G1BJL/G2AJL/G2BJL/G3Amm2mmmmkN1625406310017171717171625406310

16、02.674.176.6710.516.718.729.246.773.511766666111111.842.302.913.664.611.842.302.913.664.611.842.302.913.664.615.536.918.7411.013.864.6100.9161.5254.4403.86.089.1314.4021.6334.335.898.8313.9320.5832.676.459.7115.3322.3735.506.279.4214.8721.6334.336.8310.2516.2024.1538.331.79341.14780.71740.45550.2869

17、12512516016020061661661251251601602006.9420.48.8926.111.11321451691862111826182618171712.972.473.362.803.762.971.923.362.183.762.975.773.366.533.7614.915.716.817.718.8397.9503.9509.3644.9636.729.1745.6936.1857.6944.2228.6844.2735.2955.8643.1130.1448.5437.4261.3445.0029.6547.1236.8059.5144.2231.0451.

18、3938.6764.9946.890.23040.23100.18000.18050.144020025025031531516101671620025025031531532.624.640.721.851.32332752913373662622264526777773.133.803.502.993.932.432.112.721.993.057.306.348.165.979.1619.821.622.223.924.9806.2880.61007.71039.61269.770.1368.7287.6779.03106.8367.8567.0184.8277.51101.7074.6

19、972.1693.3782.08114.0272.4170.4490.5280.55110.4378.9375.6098.6685.13121.200.14440.11540.11550.09170.0917400400450450500713713740040045045050027.751.931.158.334.64284521815085354554455445777773.363.073.573.263.762.243.072.383.262.516.739.217.149.777.5226.927.628.529.330.11320.11510.31485.21699.11650.

20、298.36123.04107.47138.42119.4196.42117.85105.29132.58116.99102.23130.30111.82146.58124.25100.29126.67109.64142.50121.83106.10137.56115.87154.75128.740.07220.07230.06420.06430.05785005605606306301371371350056056063063064.838.770.943.679.8565599631674710544554455477197193.433.983.634.223.853.432.652.1

21、82.812.3110.37.9610.98.4411.630.931.832.733.834.71887.91848.22103.42079.22366.3153.80133.74172.59150.45191.77147.31131.03167.63147.40186.19162.87139.16182.52156.55202.94158.33136.45177.56153.50197.36171.94144.19192.45162.21213.320.05780.05160.05160.04590.0459710710800800800713481371071080080080049.1

22、89.934.666.7101759800835867901455472845471977194.484.093.763.484.342.992.452.513.482.618.9612.37.5210.413.035.936.837.638.339.12343.22666.82480.22732.73004.9169.56216.12167.41205.33243.52166.12209.83164.99198.67236.43176.43228.71172.25214.67257.71172.99222.42169.83210.00250.61182.81240.41176.74224.0

23、0270.880.04070.04070.03610.03620.03629009001000112011204844890090010001120112038.975.043.247.391.2939975104311671211728472728477719193.993.694.214.454.122.663.692.801.782.477.9811.18.418.9012.439.940.642.144.545.32790.23074.23100.33464.93811.5188.33226.50209.26234.53283.17185.61219.00206.23231.22276

24、.78193.78231.75215.31241.15295.94191.06226.50212.28237.84289.55198.83244.50220.93247.77307.790.03210.03220.02890.02580.025812501250481250125052.810213031352728419194.704.351.882.619.4013.147.047.93867.14253.9261.75316.04258.06308.91269.14330.29265.44323.16276.53343.520.02310.0232铝合金绞线和钢芯铝合金绞线Aluminu

25、m Alloy Stranded Conductor (AAAC) & Aluminum Alloy Stranded Conductor Steel Reinforced (AAACSR)一、用途 Application铝合金绞线和钢芯铝合金绞线具有强度高、载流量大、弧垂性能好的长处，并具有耐磨损、抗挤压、耐腐蚀的特性。其构造简朴、架设和维护以便、线路造价低、传播容量大。它广泛合用于多种电压级别的输配电线路和江河大跨越、重冰区等特殊地理环境的输电线路中。AAAC and AAACSR have been widely used in power transmission lines with

26、 various voltage levels, and also used in power lines across great rivers, heavy ice area, etc. with special geographical situation. The cables have excellent advantages of high strength, large current carrying capacity and good catenary property as well as wear-resistance, anti-crush and corrosion-

27、proof with simple structure, convenient installation and maintenance, low cost for the line, large transmission capacity.二、型号 Type1、铝合金绞线的型号Type of the aluminum alloy stranded conductor (AAAC) : JLHA2、JLHA12、钢芯铝合金绞线的型号Type of the common AAACSR: JLHA2/G1A、JLHA2/G1B、JLHA2/G3A、JLHA1/G1A、JLHA1/G1B、JLHA1

28、/G3A 注：LHA2为相称于53IACS的高强度铝合金线LHA1为相称于52.5IACS的高强度铝合金线Note: LHA2 is a high-strength aluminum alloy wire corresponding to 53% IACS. LHA1 is a high-strength aluminum alloy wire corresponding to 52.5% IACS.三、规格 Specification1、铝合金绞线和钢芯铝合金绞线的规格用相称于硬圆铝线的导电截面积的规格表达。面积单位为mm2。Specifications of AAAC and AAACSR

29、 are denoted with conductive cross-section of hard round aluminum wire in mm2.2、铝合金绞线的规格和产品构造见表3、表4。Specification and structure of AAAC see Table 3 and 43、 钢芯铝合金绞线的规格和产品构造见表5、表6。Specification and structure of AAACSR see Table 5 and 6.四、产品性能 Product Performance1、铝合金绞线和钢芯铝合金绞线的电性能以其20时的千米直流电阻表达。绞线所用铝合

30、金线的电阻率为：The electrical performance of AAAC and AAACSR is indicated in DC /km(20). The resistivity of aluminum alloy wire for stranded wires is:LHA1：不不小于not greater than 32.840 nm。LHA2：不不小于not greater than 32.530 nm。2、铝合金绞线的额定抗拉力以构成铝合金绞线的所有铝合金线的截面积总和与铝合金线原则规定的相应规格最小抗拉强度的乘积表达。The rated tensile strengt

31、h of AAAC is denoted with the result of total cross-section of all aluminum alloy conductors multiplied by min. tensile strength of corresponding size specified in the standard for aluminum alloy wire.3、钢芯铝合金绞线的额定抗拉力以构成钢芯铝合金绞线的铝部抗拉力与钢部抗拉力之和表达。The rated tensile strength of AAACSR is denoted with the

32、sum of all aluminum conductors tensile strength and steels tensile strength.a 铝部抗拉力以铝合金线截面积总和与铝合金线原则规定的相应规格的最小抗拉强度的乘积表达。The tensile strength of all aluminum conductors is denoted with the result of all cross-sections of aluminum alloy conductors multiplied by min. tensile strength of corresponding s

33、ize in the standard for the aluminum alloy wire.b钢部抗拉力以钢线截面积总和与钢线原则规定的相应规格的伸长1时应力的乘积表达。The tensile strength of all steel wires is denoted with the result of all cross-sections of steel wires multiplied by the stress at 1% elongation of corresponding size specified in the standard for the steel wire.

34、4、 铝合金绞线的产品性能见表3、表4。Performance of AAAC see Table 3 and 4.5、 钢芯铝合金绞线的产品性能见表5、表6。Performance of AAACSR see Table 5 and 6.五、材料原则 Material Standard1、 铝合金绞线和钢芯铝合金绞线用高强度铝合金线执行JB/T 8134-1997原则（等效采用IEC 60104：1987原则）。The high-strength aluminum alloy conductor used for AAAC and AAACSR implements the standard

35、 JB/T 8134-1997 ( equivalent to IEC 60104: 1987).2、钢芯铝合金绞线用镀锌钢丝执行IEC 60888：1987原则。The zinc coated steel wire used for AAACSR implements IEC 60888: 1987.表3 JLHA2铝合金绞线性能 Table 3 Properties of AAAC (JLHA2)规格Specification面积Areamm2单线根数No. of single wiresn直径Diameter单位长度重量Weightkg/km额定抗拉力rated tensile stre

36、ngthkN直流电阻20DC resistanceat 20/km单线single绞线strandsmmmm1625406310018.428.846.072.51157777191.83 2.292.893.632.785.496.868.6810.913.950.478.7125.9198.3316.35.438.4913.5821.3933.951.78961.14530.71580.45450.287712516020025031514418423028836319191919373.103.513.934.393.5315.517.619.622.024.7395.4506.1632

37、.7790.8998.942.4454.3267.9184.88106.950.23020.17980.14390.11510.0916400450500560630 460 518575645725 37 37 37 61 613.984.224.453.673.8927.929.631.233.035.01268.41426.91585.51778.4.7135.81152.79169.76190.14213.900.07210.06410.05770.05160.045871080090010001120125081792110361151128914396161919191914.13

38、4.383.814.014.254.4937.239.541.844.146.749.42254.82540.62861.13179.03560.53973.7241.07271.62305.58339.53380.27424.410.04070.03610.03210.02890.02580.0231表4 JLHA1 铝合金绞线性能 Table 4 Properties of AAAC (JLHA1)规格Specification No.面积Areamm2单线根数No. of single wiresn直径Diameter单位长度重量Weightkg/km额定抗拉力rated tensile

39、 strengthkN直流电阻20DC resistanceat 20/km单线single绞线strandsmmmm1625406310018.629.046.573.21167777191.84 2.302.913.652.795.526.908.7210.914.050.879.5127.1200.2319.36.049.4415.1023.0637.761.78961.14530.71580.45450.287712516020025031514518623229036619191919373.123.533.954.413.5515.617.619.722.124.8399.2511

40、.0638.7798.41008.447.2058.5673.2091.50115.290.23020.17980.14390.11510.0916400450500560630 465 523581651732 37 37 37 61 614.004.244.473.693.9128.029.731.333.235.21280.51440.51600.61795.3.8146.40164.70183.00204.96230.580.07210.06410.05770.05160.04587108009001000112082593010461162130161619191914.154.40

41、3.834.034.2737.339.642.144.446.92276.22564.82888.33209.33594.4259.86292.80329.40366.00409.920.04070.03610.03210.02890.0258表5 JLHA2/G1A、JLHA2/G1B、JLHA2/G3A 钢芯铝合金绞线性能Table 5. Properties of AAACSR (JLHA2/G1A,JLHA2/G1B,JLHA2/G3A)规格Spec.钢比St.面积Area单线根数Nos of wire单线直径Diameter of wire直径Diameter单位长度重量Weight

42、kg/km额定抗拉力Rated tensile strength直流电阻20DCresistanceat 20/km铝Al钢St总和Sum铝Al钢St铝Al钢St钢芯St core绞线StrandsJLH2/G1AJLHA2/G1BJLHA2/G3Amm2mmmmKN1625406310017171717618.428.846.072.51153.074.087.6712.16.3921.533.653.784.6121666618111111.982.473.133.922.851.982.473.133.922.851.982.473.133.922.855.937.419.3811.81

43、4.374.4116.2185.9292.8366.49.0213.9622.0234.6841.248.8113.6221.2533.4840.799.8815.2524.1737.5842.971.79341.14780.71740.45550.286912512516016020061661661441441841842307.9923.410.230.012.8152167194 2142431826182618171713.192.653.613.004.043.192.063.612.344.043.196.193.617.014.0416.016.818.019.020.2458

44、.0579.9586.2742.3732.851.2369.8665.5888.5281.9750.4368.2264.5686.4280.6953.4776.4268.0396.6185.040.23040.23100.18000.18050.1440200250250315315161016716230288 28836336337.528.346.925.159.0 268316335 3884222622264526777773.364.083.753.204.212.612.272.922.143.287.836.808.766.419.8321.323.123.825.626.79

45、27.91013.51159.81196.51461.4110.64117.09138.31136.28171.90108.02115.12135.03134.52166.00120.77124.72150.96143.30188.440.14440.11540.11550.09170.0917400400450450500713713746046051851857531.859.735.867.139.84925205545856154554455445777773.613.293.833.494.042.413.292.553.492.697.229.887.6610.58.0728.92

46、9.730.631.532.31519.41738.31709.31955.61899.3172.10201.46193.61226.64215.12169.87195.49191.10219.93212.33180.69218.17203.28245.44225.860.07220.07230.06420.06430.057850056056063063013713413575645 64572572574.644.681.631.391.8650689726756817544554725477197193.684.273.903.584.133.682.852.342.392.4811.1

47、8.5411.77.1612.433.234.235.135.837.22172.92127.22420.92248.02723.5251.82240.93283.21249.62318.61244.36237.82277.49247.43312.18269.73252.97305.25258.08343.40.05780.05160.05160.04590.0459710710800800900413484817817921921103635.310439.876.744.8852921961997108172547284727197773.804.394.043.7440282.532.6

48、32.693.742.857.6013.28.0711.28.638.039.540.441.142.82533.43069.42854.63145.13211.4281.32359.06316.98356.03356.60278.85351.82314.19348.35353.47290.85387.01327.72374.44368.690.04070.04070.03610.03620.03219001000112088810361151128986.393.7105112212451394848484719193.964.184.423.962.512.6511.912.513.343

49、.645.948.63538.33916.84386.8400.53446.37499.93391.90439.81492.59421.25471.67528.270.03220.02890.0258表6 JLHA1/G1A、JLHA1/G1B、JLHA1/G3A 钢芯铝合金绞线性能Table 6. Properties of AAACSR (JLHA1/G1A,JLHA1/G1B,JLHA1/G3A)规格Spec.钢比St.面积Area单线根数No. of wire单线直径Diameter of wire直径Diameter单位长度重量Weightkg/km额定抗拉力Rated tensil

50、e strength直流电阻20DC/km铝Al钢St总和Sum铝Al钢St铝Al钢St钢芯St core绞线StrandsJLHA1/G1A JLHA1/G1BJLHA1/G3Amm2mmmmKN1625406310017171717618.629.046.573.21163.104.847.7512.26.4621.733.954.285.4123666618111111.992.483.143.942.871.992.483.143.942.871.992.483.143.942.875.967.459.4211.814.375.1117.3187.7295.6369.99.6714.9

51、622.6336.4845.129.45 14.6222.85 35.26 44.6710.5316.2725.7939.4146.861.79341.14780.71740.45550.288012512516016020061661661451451861862328.0723.710.330.312.9153169196 2162451826182618171713.212.673.633.024.053.212.073.632.354.053.216.223.637.044.0516.016.918.119.120.3462.3585.4591.8749.4739.856.0874.8869.9294.9487.4055.2778.2268.8992.8286.1158.3481.572.40103.1190.500.23040.23100.18000.18050.1444200